17
Table 2 – Inspection and Maintenance Log
Inspection Date: Inspected By:
Component: Inspection: (See Section 2 for Inspection Frequency) User Competent
Person
R550 Device
(Figure 2)
Inspect for loose fasteners and bent or damaged parts.
Inspect the Housing Assembly (A), Rope Sheave (B), Anchor Loop (D),
Thimble (F), and Rescue Hub (H) for distortion, cracks, or other damage.
If the R550 Device is stored in a Humidity Resistant Case, inspect
the Humidity Indicator on the outside of the case (see Figure 12). If
the Humidity Indicator displays a reading of 60 or greater (pie sector
indicator): (1) Open the case and inspect the R550 Device per the
remaining steps. (2) Maintain the case as described in Section 6.1.
Ensure the Lifeline (C) pulls through the device smoothly. Inspect the
entire rope for cuts, burns, severely abraded areas, and excessive wear.
Inspect the Carabiner (E) and Snap Hooks (G) for damage, corrosion, and
working condition.
Inspect the entire unit for signs of corrosion.
Labels
(Figure 15)
Ensure that all labels for all products are present and fully legible.
PFAS and Other
Equipment
Additional Personal Fall Arrest System (PFAS) equipment (harness, SRL,
etc) that are used with the Anchorage System should be installed and
inspected per the manufacturer’s instructions.
Structure Verify the structure to which the structure is attached meets the strength
requirements from Table 1 in all possible directions of loading.
Serial Number(s): Date Purchased:
Model Number(s): Date of First Use:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
Corrective Action/Maintenance: Approved By:
Date:
To Next Page
Loading...
