All-Power APG3203 User Manual

27 pages

To Next Page

Operator’s Manual

APG3203

Model

WARNING

READ AND FOLLOW ALL SAFETY RULES AND INSTRUCTIONS IN THIS MANUAL

BEFORE ATTEMPTING TO OPERATE THIS MACHINE. FAILURE TO COMPLY WITH

THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY.

Diagrams within this manual may not be drawn proportionally. Due to continuing improvements,

actual product may differ slightly from the product described herein.

7000 Watt

Diesel Generator

Questions and Answers:

J
Joseph GonzalezJul 30, 2025
What to do if my All-Power Inverter generator is not producing power?
- A
  Andrew KellyJul 30, 2025
  If your All-Power Inverter generator isn't producing power, start by checking if the AC circuit breaker switch is turned on; if not, switch it to the ON position. A worn carbon brush can also cause this issue, requiring a replacement. Inspect the power outlet for poor contact and adjust if necessary. Ensure the generator reaches the rated speed by making adjustments as needed. A damaged AVR could also be the cause, and it would need to be replaced.
H
Heather WillisAug 14, 2025
Why won't my All-Power APG3203 Inverter diesel engine start?
- D
  Donald MeyerAug 14, 2025
  If your All-Power Inverter's diesel engine won't start, several factors could be at play. Ensure you have enough fuel by refilling the tank. Check that the fuel valve is open. Make sure the engine start lever is in the RUN position. Verify the oil level is adequate, positioned between the upper and lower marks. If the battery is weak, charge or replace it. Insufficient force when pulling the recoil starter can also prevent starting, so adhere to the correct start procedure.

All-Power APG3203 Specifications

General

Power Output	3200W
Rated Watts	2800W
Starting Watts	3200W
Peak Power	3200W
Input Voltage	12V DC
Output Voltage	120V AC
Frequency	60Hz
Waveform	Pure Sine Wave
Run Time	8 hours at 50% load
AC Outlets	2 x 120V 20A
DC Outlets	1
Protections	Overload

Summary

Safety Warnings

Fire Prevention

Instructions to prevent fire hazards related to the generator, including fueling and ventilation.

Exhaust Fume Safety

Guidelines to prevent inhalation of dangerous carbon monoxide from generator exhaust.

Burn Prevention

Warning to avoid touching hot engine parts like the muffler to prevent severe burns.

Electrical Safety

Precautions against electrical shocks and short circuits, including grounding and wet conditions.

Cautionary Guidelines

Overload and Circuit Protection

Battery Handling Precautions

Safety measures for handling batteries, including acid exposure and explosive hydrogen gas.

Carbon Monoxide Danger

Technical Specifications

Pre-Operation Checks

Diesel Fuel Handling

Instructions for selecting, handling, and refueling diesel fuel safely and correctly.

Engine Oil Level Check

Procedure for checking and refilling engine oil, with warnings about insufficient or excess oil.

Air Filter Servicing

New Generator Break-in Procedure

Starting the Generator

Electric Starting Procedure

Step-by-step guide for starting the generator using the electric starter system.

Operating Your Generator

Operational System Checks

Generator Load Capacity

AC Load Application

DC Load Application

Stopping the Generator

Periodic Maintenance

Engine Oil Replacement

Air Filter Maintenance

Fuel Filter Servicing

Battery Refilling and Charging

Troubleshooting and Solutions

Related product manuals