Home
Audi
Automobile
R8 LMS 2018
Page 63 (Rear Axle, Anti-roll Bar and Dampers)
Audi R8 LMS 2018 - Rear Axle, Anti-roll Bar and Dampers
113 pages
Manual
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
500
- Rear Axle, Anti-roll Bar and Dampers
Version 1
201
6-
01
-
01
63
/
113
500
- Rear Axl
e, Anti-roll Bar and Da
mpers
For
current
info
rmation,
se
e
chapter
400
–
Front
Axle,
Anti-Roll
Bar,
Dampers
and Steering.
62
64
Table of Contents
Main Page
Default Chapter
2
Table of Contents
2
List of Images
4
List of Abbreviations
6
Miscellaneous
7
Car Views
8
Air Jack and Fire Extinguisher
11
Air Jack System
11
Fire Extinguisher System 596
14
Engine Ancillaries, Oil Tank and Water Cooler
18
Drivetrain
18
1.1 Engine
18
1.2 Engine Lubrication
20
Image 1: Adding Engine Oil During Endurance Races
22
1.3 Engine Cooling System
24
Image 2: Scheme of Cooling System
24
Image 3: Expansion Reservoir
28
1.3 Clutch - Flywheel
29
Fuel Cell and Exhaust System
30
Fuel Cell
30
1.1 Refuelling Valve Service Instructions
30
Image 4: Refuelling Coupling, Service Tool and Molykote 1292 Grease
30
Image 5: Using Service Tool, Refuelling Coupling in Service Position
31
Image 6: Using Service Tool, Lubricating O-Rings
31
Service Instructions Refuelling Coupling
33
Image 7: Refuelling Coupling and Molykote 1292 Grease
33
Image 8: Service Tool Decoupled and Unlocked
34
Image 9: Service Tool Fitted, Locked and Open
34
Gearbox, Drive Shafts and Ancillary Components
36
Image 10: Gearbox - FIA Homolagated Gear Ratios
36
Image 12: Screw Plug, Adjustable Differential Preload
39
Image 13: Adjustable Preload
39
Front Axle, Anti-Roll Bar, Dampers and Steering
40
Filling / Bleeding Steering System
40
Miscellaneous
42
2.1 Suspension Geometry Curves
44
2.2 Springs
46
2.3 Anti-Roll Bars
47
2.4 Damper / Ride Height Adjustment
49
Image 14: Push Rod Thread with Groove Marking
51
Image 15: Lower Damper Eye in Maximum Permitted Position
51
Image 16: Characteristic Curve Front Damper 4SA 412 019 B
53
Image 17: Characteristic Curve Rear Damper 4SA 512 019 C
53
2.5 Camber Adjustment
54
2.6 Toe Rods / Toe Adjustment
56
2.7 Brake Discs
57
Image 18: Front Axle Brake Cooling Duct Without Blanking
61
Image 19: Front Axle Brake Cooling Duct with Blanking
61
500- Rear Axle, Anti-Roll Bar and Dampers
63
600- Brake Pipes, Brake Cooling Ducts, Wheels and Tyres
64
700- Pneumatic Gearshift and Pedals
65
Pedals
65
1.1 Longitudinal Adjustment Pedal Unit
65
Image 20: Rails with Ratchet and Detent Mechanism
65
Image 21: Centre Console with Button to Disengage Pedal Unit and Main Switch to Activate Compressor
66
Image 22: Push Surface on the Pedal Unit Cover
67
1.2 Throttle Pedal
69
Image 23: the Two Possible Throttle Pedal Plate Positions
69
Image 24: Nut to Adjust Spring Preload on Throttle Pedal
70
Throttle Pedal
70
Image 26: Pedal Assembly - Throttle Pedal Damper
71
Image 27: Adjusting the Throttle Pedal Damper
73
1.3 Brake Pedal
74
Plate
74
Image 29: Setting Brake Pedal Plate 20 MM in Front of Throttle Pedal Plate
74
Image 30: Brake Pedal Plate Long Side Left
75
Image 31: Brake Pedal Plate Long Side Right
75
Image 32: Brake Pedal Plate Height Adjustment
76
Image 33: Brake Pedal Plate Angle Adjustment
76
800- Bodywork, Chassis Parts, Seat and Air Conditioning
77
Seat
77
1.1 Homologation
77
Image 34: Audi Safety Seat PS1
77
1.2 Seat Sizes
79
1.3 Cushions
80
1.4 Additional Inserts
81
1.5 Shoulder Strap Mounting
82
Image 35: Shoulder Strap Mounting below Roll-Cage Tube
82
Image 36: Shoulder Strap Mounting above Roll-Cage Tube
82
801- Aerodynamics
83
Aero Set-Up Sheet
83
Image 37: Rear Wing Adjustment Range
83
900- Electric and Data Acquisition
87
Software
87
Diagnosis
95
901- Engine Warm-Up Procedure / Engine Start
98
Preparation before Engine Start
98
1.1 Checking / Adjusting Gearbox Potentiometer
98
Image 38: Shift Barrel in Neutral (N) Position
99
Image 39: Adjusting the Gearbox Potentiometer
99
1.2 Checking Engine Oil Level
100
1.3 Checking Gearbox Oil Level
101
1.4 Fuel, Coolant and Coolant Additive, Steering Oil and Brake Fluid
102
Image 41: Coolant Expansion Reservoir
102
1.5 Preparation Warm up Procedure / 'Warm up
104
Warming up / Cooling down the Engine and Gearbox
105
2.1 Warm up Procedure
105
2.2 Cooling down Procedure
106
Service and Maintenance Contacts
107
Related product manuals
Audi R8
46 pages
Audi R8 2008
272 pages
Audi R8 2015
77 pages
Audi R8 2021
9 pages
Audi R8 2017
300 pages
Audi R8 2010
260 pages
Audi R8 2009
276 pages
Audi R8 2014
236 pages
Audi R8 Spyder
6 pages
Audi R8 Spyder 2012
236 pages
Audi R8 Spyder 2011
244 pages
Audi R8 Spyder 2014
244 pages
To Next Page
