Bad Boy INSTINCT User Manual

SPECIFICATIONS
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
Page 2 - 2
2
VHEICLE SPECIFICATIONS
Specifications are subject to change without notice
* Field installed accessories may require installation charges
MODEL: INSTINCT
TYPE: ELECTRIC OFF ROAD VEHICLE
MODEL YEAR: 2013
Part No: 629234
Programmable AC Drive System:
Factory programmable to application
z
Solid State variable frequency AC speed controller
z
300 Amp AC Controller
z
Drive-by-wire electronic throttle control
z
Full torque, reduced speed reverse
z
Console mounted direction selector switch (Forward-Neutral-Reverse)
z
Sealed Hall effect throttle sensor
z
Descent speed control
z
Full diagnostic capability (Hand held diagnostic unit)
z
Full-time regenerative braking
z
Dash mounted Max Speed/Max Range speed selector switch
Motor:
Battery Charger:
Remote 72 VDC DPI Charger, 120 VAC 60 Hz or optional 230VAC 50Hz unit. (U.L. Certified)
Electrical System:
72 Volt DC, six 12 volt deep cycle storage batteries
Drive Train:
Direct motor shaft connected to transaxle pinion shaft
Transaxle:
Differential with reverse helical gears
Brakes:
4-wheel hydraulic disc brakes and Induction motor. Manual parking brake
Body Protection: Front Brush Guard
Performance
Overall Length in cm Seating Capacity & Style 2 Persons - Bench Seat
Overall Width in cm Curb Weight lb kg
Overall Height in cm Vehicle load capacity lb kg
Wheel Base
in cm Gross Axle Weight Rating - F lb kg
Gnd Clearance @ Frame in cm Gross Axle Weight Rating - R lb kg
Gnd Clearance @ Differential in cm Outside Clearance Circle ft m
Vehicle Power Speed - Low (Level Ground) mph kph
Power Source 72 Volts DC Speed - High (Level Ground) mph kph
Motor Type 72 Volts AC Speed - Reverse mph kph
Horsepower (kW)
hp kW Steering & Suspension
Electrical System
72 Volt Steering
Double Ended Rack & Pinion - 3.69 turns to lock
Batteries (Qty, Type) Six 12V Deep Cycle Front Suspension MacPherson Strut
Key or Pedal Start Key Start
Rear Suspension
MacPherson Strut
Speed Controller 300 amp Service Brake 4-Wheel Hydraulic Disc with Motor Regen
Drive Train Motor Shaft Direct Drive Parking Brake Manual w/controller cut-out
Transaxle Hardened Helical Gears Tires / Wheels 25X10-12 Mud-Lite / 12" Black Steel
Direction Selection Console mounted Forward-Neutral-Reverse
Body & Chassis
Speed Selection Dash mounted Speed/Range switch Frame Welded Steel with DuraShield powder coat
Rear Axle Ratio Body & Finish Injection Molded TPO & Automotive Style Paint
Front Axle Ratio
Standard Color Matte Black
Cargo Bed 9.7 Cu. Ft. Polyethelyne Bed
Some items shown may be optional equipment
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
One 72 Volt AC induction motor, solid copper windings. 19 hp (12.4 kW) peak. AC system reads motor speed for accurate speed control
in all conditions. Regenerative braking for maximum economy
Dimensions
12.4
16.5 42
693
381
257
817
175
10.0 25
19
PRODUCT OVERVIEW
111.0 282
52.0 132
76.5 194
(F&R)
12.49:1
24.5
1,528
840
567
1,801
10.0
7.5
16.1
24
16.0 25.7
39.4
69.0

Bad Boy INSTINCT Specifications

General

Brand	Bad Boy
Model	INSTINCT
Category	Offroad Vehicle
Language	English