Bosch Tronic 5000 Series - English; Table of Contents

Table of contents
Tronic 5000 – 6721830067 (2021/06)
2
Table of contents
1 Explanation of symbols and safety instructions . . . . . .3
1.1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . .3
1.2 General safety instructions . . . . . . . . . . . . . . . . . . . .3
2 Standards, regulations and directives . . . . . . . . . . . . . .6
3 About the appliance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.1 Declaration of conformity . . . . . . . . . . . . . . . . . . . . .6
3.2 Use according to the provisions of applicable
regulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.3 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.4 Appliance accessories. . . . . . . . . . . . . . . . . . . . . . . .6
3.5 Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.6 Appliance design . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
3.7 Transportation and storage. . . . . . . . . . . . . . . . . . . .8
4 User Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
4.1 Operating panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
4.2 Before commissioning the appliance . . . . . . . . . . . .9
4.3 Switching the appliance on/off. . . . . . . . . . . . . . . . .9
4.3.1 LED status display . . . . . . . . . . . . . . . . . . . . . . . . . . .9
4.4 Temperature control . . . . . . . . . . . . . . . . . . . . . . . . .9
4.4.1 Operating modes. . . . . . . . . . . . . . . . . . . . . . . . . . . .9
4.4.2 Minimum and maximum temperature . . . . . . . . . 10
4.4.3 Winter operation . . . . . . . . . . . . . . . . . . . . . . . . . . 10
4.5 Start-up after a power failure . . . . . . . . . . . . . . . . 10
4.6 Start-up after a water supply cut. . . . . . . . . . . . . . 10
4.7 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
4.8 Reset internal counters . . . . . . . . . . . . . . . . . . . . . 11
4.9 Connectivity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
4.10 Customer Service . . . . . . . . . . . . . . . . . . . . . . . . . 11
5 Installation (only for approved contractors). . . . . . . 11
5.1 Important information . . . . . . . . . . . . . . . . . . . . . . 11
5.2 Choose the installation site . . . . . . . . . . . . . . . . . . 12
5.3 Unpack and remove the cover of the
appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
5.4 Water connection. . . . . . . . . . . . . . . . . . . . . . . . . . 14
5.5 To mount the appliance on the wall. . . . . . . . . . . . 15
5.6 Electrical installation of the appliance . . . . . . . . . 16
5.7 Hydraulic block assembly . . . . . . . . . . . . . . . . . . . 18
5.8 Aquastop installation . . . . . . . . . . . . . . . . . . . . . . . 19
5.9 The air must be purged from the appliance . . . . . 21
5.10 Appliance configuration . . . . . . . . . . . . . . . . . . . . 21
5.10.1 Configure the power level. . . . . . . . . . . . . . . . . . 22
5.10.2 Setting maximum temperature . . . . . . . . . . . . . 22
5.10.3 Configuring and installing a Priority Relay. . . . . 22
6 Electrical connection (only for approved
contractors) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
6.1 Electrical connection. . . . . . . . . . . . . . . . . . . . . . . 23
6.2 Install the appliance cover. . . . . . . . . . . . . . . . . . . 24
7 Commissioning of the appliance. . . . . . . . . . . . . . . . . 25
7.1 First commissioning of the appliance. . . . . . . . . . 25
7.2 Removing/Replacing the flow limiter . . . . . . . . . . 26
8 Maintenance (only for approved specialists) . . . . . . 26
9 Problems. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
10 Technical information. . . . . . . . . . . . . . . . . . . . . . . . . . 28
10.1 Tech data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
10.2 Product data for energy consumption . . . . . . . . . 29
11 Environmental protection and disposal . . . . . . . . . . . 30
12 Data Protection Notice . . . . . . . . . . . . . . . . . . . . . . . . . 30