Brother HL-2060 - Page 6

iii
1.19 Tray Sensor Holder........................................................................................................ IV-17
1.20 Roller Holder .................................................................................................................. IV-18
1.21 Paper Pick-up Roller Assy, Bearing............................................................................... IV-18
1.22 Paper Pick-up Solenoid.................................................................................................. IV-20
1.23 Paper Feed Motor Assy ................................................................................................. IV-20
1.24 MP Tray Cover............................................................................................................... IV-21
1.25 MP Tray Assy................................................................................................................. IV-22
1.26 Paper Path Separation Plate, Paper Path Separation Film ........................................... IV-23
1.27 Latch .............................................................................................................................. IV-23
1.28 Fixing Unit (for both 120V and 230V, the only difference is the halogen heater)........... IV-24
1.29 Transfer Unit .................................................................................................................. IV-27
1.30 DC Gear Holder Assy .................................................................................................... IV-28
1.31 PS Switch Wire, Remote Switch .................................................................................... IV-29
1.32 High-Voltage Power Supply PCB Assy.......................................................................... IV-29
1.33 Low-Voltage Power Supply PCB Assy........................................................................... IV-30
1.34 Toner Cartridge (EP-ED HC Cartridge) ......................................................................... IV-31
1.35 Paper Tray ..................................................................................................................... IV-32
CHAPTER V MAINTENANCE AND SERVICING............................V-1
1. PERIODICAL REPLACEMENT PARTS ........................................................ V-1
2. CONSUMABLE PARTS STANDARD ENDURANCE TABLE ........................ V-1
3. LIST OF STANDARD TOOLS........................................................................ V-2
4. LIST OF LUBRICANTS AND CLEANERS..................................................... V-3
CHAPTER VI TROUBLESHOOTING..............................................VI-1
1. INTRODUCTION .......................................................................................... VI-1
1.1 Initial Check........................................................................................................................ VI-1
1.2 Basic Procedure................................................................................................................. VI-2
2. TEST PRINTING AND MECHANICAL CHECK ............................................ VI-2
2.1 Test Printing....................................................................................................................... VI-2
3. IMAGE DEFECTS......................................................................................... VI-3
3.1 Image Defect Examples..................................................................................................... VI-3
3.2 Troubleshooting Image Defects......................................................................................... VI-4
4. TROUBLESHOOTING OF MALFUNCTIONS............................................. VI-11
5. TROUBLESHOOTING PAPER TRANSPORT PROBLEMS....................... VI-18
5.1 Paper Jams...................................................................................................................... VI-18
5.2 Incomplete Paper Feed.................................................................................................... VI-21