Chicago Electric CORDLESS SPRAY GUN 90880 User Manual (English)

Questions and Answers:

T
Troy MartinJul 28, 2025
Why Chicago Electric Paint Sprayer motor hums but no spraying occurs?
- N
  Nathan NelsonJul 28, 2025
  If your Chicago Electric Paint Sprayer motor hums but no spraying occurs, or the spraying is irregular, here are some possible causes and solutions: * **Worn Valve:** Replace the valve. * **Piston Stuck:** Clean the piston with thinner. * **Suction Tube not in place:** Adjust the suction tube. * **Blocked Suction Tube and/or Filter:** Clean the suction tube and filter with thinner. * **Blocked Nozzle:** Clean the nozzle with thinner. * **Loosened Lock Nut:** Tighten the lock nut.
R
Robert PatrickAug 2, 2025
What to do if my Chicago Electric Paint Sprayer operating sound not normal?
- D
  dcarpenterAug 2, 2025
  If the operating sound of your Chicago Electric Paint Sprayer is not normal, consider the following: * **Poor output adjustment:** Adjust the Spray Control Regulator to reduce spraying volume. * **Not enough paint in the Canister:** Refill the canister with paint. * **Not diluted properly or not passing through the Suction Tube:** Check the Suction Tube and paint viscosity. * **Battery charge is low:** Recharge the battery.
T
Teresa HarrisAug 6, 2025
How to stop over painting and dripping with Chicago Electric Paint Sprayer?
- L
  Lawrence MoraAug 6, 2025
  To prevent over painting and dripping with your Chicago Electric Paint Sprayer: * Keep the spray gun 10” to 12” from the surface. * Adjust the Spray Control Regulator to reduce spraying volume. * Check paint viscosity.
B
Brandon CareyAug 10, 2025
Why is spray atomization not good with Chicago Electric Paint Sprayer?
- R
  Raymond BellAug 10, 2025
  If the spray atomization is not good with your Chicago Electric Paint Sprayer, it might be because the nozzle or lock nut is not tightened properly. Tighten the nozzle and lock nut. Also, check the viscosity of the paint, as it might be too thick.
K
Kenneth MartinAug 14, 2025
How to fix orange peel effect and excessive fogging with Chicago Electric Paint Sprayer?
- Q
  qsmithAug 14, 2025
  To address the orange peel effect and excessive fogging when spraying with your Chicago Electric Paint Sprayer: * Ensure you are using the correct thinner and completely clean the spray gun components before starting again. * Hold the spray gun closer to the surface. * Check if the paint is too thick or too thin.
B
Brenda StewartAug 18, 2025
Why Chicago Electric Paint Sprayer operates only for a short time?
- P
  Paige HillAug 18, 2025
  If your Chicago Electric Paint Sprayer operates only for a short time, it could be due to the following reasons: * The battery is not fully charged: Fully charge the battery. * The charger is defective: Replace the charger base and/or AC adapter. * The battery life has expired: Replace the battery with the same type.
N
Nicole MccormickAug 23, 2025
Why is the motor on my Chicago Electric Paint Sprayer louder than normal?
- E
  Emily CoxAug 23, 2025
  If the motor of your Chicago Electric Paint Sprayer is louder than normal, it may be because the spray gun components are not clean or lubricated. Disassemble and clean the spray gun components, and then lubricate them.