Home
Club Car
Automobile
CARRYALL 300 GASOLINE
Club Car CARRYALL 300 GASOLINE User Manual
5
of 1
of 1 rating
102 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
CARRYALL
300
GASOLINE
Operators
Manual
APPLICABLE
TO
CARRYALL
300
ECH440
GASOLINE
VEHICLES
WITH
SERIAL
PREFIX
OF
MC
2
Table of Contents
Introduction
3
Table of Contents
7
Notices
11
Section 1 - Safety Information
11
General Safety Information
12
Practice Safety
12
Safety Signal Words
12
Safety Committee
13
Vehicle Safety Information
13
Vehicle Safety and Compliance Decals
14
Vehicle Safety Features
17
Multi-Purpose Buzzer
17
Falling Object Protection System
17
Battery Safety Information
18
Battery International Safety Symbols
18
Lead-Acid Battery Recycling
19
Section 2 - Indicators, Gauges, and Displays
21
Indicator, Gauge, and Display Locations
22
Fuel Gauge/Hour Meter
22
Low Oil Warning Light
22
Malfunction Indicator Light
23
Section 3 - Vehicle Controls
25
Vehicle Controls Locator
26
Accelerator Pedal
27
Brake Pedal
27
Electric Bed Lift Switch
27
Forward / Neutral / Reverse Control
27
Hazard Light Switch
28
Headlight Switch
28
Horn
28
Key Switch
29
Maintenance/Operate Switch
29
Park Brake
30
Turn Signal Lever
30
Windshield Wiper Switch
30
Modular Cab Controls
31
Defrost and Heater Switch
31
Dome Light Switch
31
Lower Dash Fan Switch
31
Strobe Light Switch
31
Upper Cab Fan Switch
32
Windshield Washer Switch
32
Section 4 - Vehicle Features
33
Vehicle Features Description
34
Electric Bed Lift
34
Electric Bed Lift Description
34
Electric Bed Lift Capacity
34
Electric Bed Lift Operation
34
Limited Slip Transaxle
34
Modular Cab
35
Tilt Cargo Bed
35
Tilt Cargo Bed Description
35
Tilt Cargo Bed Operation
35
12-Volt Power Receptacle
36
Versattach System
37
Section 5 - Vehicle Specifications
39
Dimensions
40
Performance
40
Tires
40
Gasoline Engine
40
Battery
41
Noise and Vibration
41
Transaxle
41
Vehicle Weights and Load Capacities
41
Section 6 - Vehicle Operation
45
Daily Pre-Operational Safety and Performance Checks
47
Overview
47
Daily Pre-Operational Safety Checklist
48
Vehicle Performance Inspection
48
Vehicle Movement
50
Overview
50
Engine Start
50
Turn off Engine
51
Forward Movement
51
Reverse Movement
52
Slow or Stop the Vehicle
52
Park the Vehicle
52
Driving Conditions
52
Unpaved Surfaces
52
Uphill Slope
53
Side Hill Slope
53
Downhill Slope
54
Over Obstacles
55
Below Obstacles
55
Night Time
55
Through Water
56
With Cargo
56
Section 7 - Vehicle Maintenance
59
Disable the Vehicle
61
Vehicle Cleaning
61
Cleaning the Windshield
61
Cleaning the Vehicle Exterior
61
Cleaning the Vehicle Interior
62
Maintenance Schedule
62
Maintenance Schedule Overview
62
Maintenance Service Schedule
62
Maintenance Tasks
63
Air Filter
63
Engine Oil
64
Refuel
69
Lift the Vehicle
70
Lower the Vehicle
71
Spark Plug
73
Tire Pressure Measurement
74
Wheel Assembly
75
Section 8 - Battery Maintenance
77
Battery Cleaning
78
Battery Charging
78
Jump Start with Battery Charger
78
Battery Electrical Connection
78
Disconnect
78
Connect
79
Section 9 - Transport and Tow
81
Prepare the Vehicle to be Towed
82
Tow with the Vehicle
82
Vehicle Transport Preparation
82
Vehicle Transport Recovery
83
Section 10 - Extended Storage
85
Extended Storage Preparation
86
Return to Service from Extended Storage
88
Section 11 - Warranties
89
Limited Warranty
90
Warranty
90
Warranty Timeframe
90
Exclusions
91
Voiding of Warranty
92
Sole Remedy
92
Disclaimer
92
No Consequential Damages
92
How to Make a Warranty Claim
92
Federal Emissions Component Defect Warranty
93
Warranty Coverage
93
Warranty Period
93
Parts Covered
93
Distribution Center
94
Warranty Service
94
What Is Not Covered
95
Owner's Responsibilities
95
Things to Know about the Emission Control System Warranty Maintenance and Repairs
95
How to Make a Claim
96
California Evaporative Emission Control Warranty Statement
96
Your Warranty Rights and Obligations
96
Manufacturer's Warranty Coverage
96
Owner's Warranty Responsibilities
96
Defects Warranty Coverage
97
Evaporative Emissions Warranty Parts List
98
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Club Car CARRYALL 300 GASOLINE and is the answer not in the manual?
Ask a question
Club Car CARRYALL 300 GASOLINE Specifications
General
Brand
Club Car
Model
CARRYALL 300 GASOLINE
Category
Automobile
Language
English
Need help?
General
To Next Page