dji D12000iE - Replacing Engine Oil

10
EN
Contact a DJI-authorized dealer or DJI Support to perform the maintenance items marked with an asterisk. For
any other maintenance items not covered by this document, contact a DJI-authorized dealer or DJI Support.
Item
Every
operation
Every 10
operating
hours
Every 20
operating
hours
Every 50
operating
hours
Every 100
operating
hours
Every 300
operating hours/1
year
Engine Oil
Level check √
Replacement* First Use √
Air Filter Sponge
Filter Element
Check/Cleaning √
Replacement* √
Air Filter Paper
Filter Element
Check/Cleaning √
Replacement* √
Spark Arrestor Cleaning √
Spark Plug
(Model: F7RTC)
Check/Cleaning/
Replacement*
√
Valve Clearance Adjustment* √
Fuel Passage
Cleaning/
Replacement*
√
Fuel Pipe Replacement* Every 2 years (or when necessary)
• A maintenance interval of every 300 operating hours/1 year means the user should perform maintenance based on
which scenario occurs rst.
• The fuel passage maintenance after 300 operating hours means that users should contact a DJI-authorized dealer or
DJI Support to check or replace the built-in lter mesh of the electronic fuel pump and clean the fuel passage and fuel
injection unit. The replacement interval varies depending on the quality of the fuel. The interval should be shortened if
the fuel quality is poor.
• Engine oil consumption increases if using the generator in high temperature environments. Fill up the engine oil to the
rated level before each use and shorten the interval of replacing the engine oil.
Checking the Engine Oil Level
1. Stop the generator and place it on a at surface.
2. Unscrew the dipstick and wipe it out with a clean
cloth.
3. Insert the dipstick as shown without screwing it
in. Take the dipstick out and check the oil level.
4. Add the recommended type of engine oil to the
upper limit position if its level is near or below the
lower limit mark. DO NOT add too much engine
oil. Otherwise, the oil may spill.
5. Install the dipstick and tighten it.
Upper Limit
Lower Limit
Fill Port Dipstick
• Damage to the generator caused by running with a low engine oil level is not covered by warranty.
• Damage to the engine resulting from failure to replace the engine oil by following the maintenance schedule is not
covered by warranty.
• Damage to the engine caused by use of non-recommended engine oil is not covered by warranty.