Maintenance & Adjustment
D760.H03E-001.H1907 171
Inspection of Clutch Fluid Level
This inspection is not required for model with AMT.
Normal replacement
Check the maintenance period refer to
page 208
The clutch reservoir is located inside the
front face shield in the cab. Under normal condi-
tions, the level of the fluid reservoir should be
near the MAX mark. Add fluid if the level is
below MIN mark. Check the pipeline system for
leakage before filling. If any leakage presents,
please repair it before filling.
CAUTION:
1.Never use the brake fluid of different quality or different grades.
2.It is strictly prohibited to use mineral oil as brake fluid, and confirm
that the clean brake fluid is used.
3.Never have the brake fluid contact any painted surface so as to avoid
damage to paint film.
4.Pay special attention to sealing and preservation.
5.Never allow dirt or dust into the reservoir.
Check and replace transmission oil
ZF12 AMT
Replacement period of transmission fluid
In order to ensure safe and reliable opera-
tion of the transmission, it is required to replace
the fluid within the specified period.
Normal replacement
Every 240,000km or 24 months
Filling volume
The filling volume of transmission fluid is
noted on the nameplate. Do replacement of fluid
as required by the fluid replacement prÂșCedures to ensure correct filling volume.
Replacement of transmission fluid
Always park the vehicle on the flat ground and shut the engine down before fluid
replacement.
It is proper to replace the fluid when the vehicle is still hot after long-distance driv-
ing, because the fluid at this time is still at the working temperature and has a low vis-
cosity, allowing for easy flow.
1. Clutch fluid reservoir
1. Drain plug
2. Drain plug
3. Filler
To Next Page
Loading...