IMPORTANT MAINTENANCE INFORMATION ON THE RIGGING:
• Always check the rigging, halyards, reefing lines, water stays and rudder down haul
line, as well as the cable operating the swing wing system in the aft wing.
• Minimum once a year shorten all halyards, reefing lines, and swing wing lines by
approx. 25 cm. After some years turn them around or replace the lines.
• Water stays, Touring and Sport version: max. 10 years use and/or max. 15,000 NM.
• Water stays, Performance version: max. 7 years use and/or max. 10,000 NM.
• Side stays and forestay should be changed latest after 10 years or by max 15,000 NM.
• Diamond stays on the mast should be changed latest after 15 years or by max 20,000
NM.
• We recommend changing the Beamstopcable under the Trampoline from centerhull
to forward outside Beam every max. 10 years.
• Never use shackles or similar on the boatman chair.
• Never climb the rigging when the boat is in folded position.
• Tension on the rigging, please see rig diagram.
• Never change the tension on the diamonds without checking tension with a tension
meter according to rig tension diagram, changing the rig tension cause the mast to
break.
• Never drill holes in the carbon mast section without asking your local dealer or
Quorning Boats beforehand.
• Never wrap the mast in any plastic, as this can cause the paint to bubble. If wrapping
is needed, use breathable textile.
• Wash the mast track with soap and water before stepping the mast.
To Next Page
