32
Appendix
Appendix
DDEC V Vehicle Interface Harness
GOVERNOR
C
B
A
C
B
A
40106
MUST PROVIDE IGNITION POWER
IN RUN AND CRANK MODES.
DO NOT SOURCE ANY NON-DDEC
ACCESSORY FROM IGN CIRCUIT (V-15)
V-11
V-14
V-60
SENSOR SUPPLY #1
VSG
SENSOR RETURN #1
CAVITY
V-11
V-13
V-60
LABEL
SENSOR SUPPLY #1
ALSG
SENSOR RETURN #1
CAVITY
V-61
V-62
V-65
V-66
LABEL
BATTERY (+)
BATTERY (+)
BATTERY (+)
BATTERY (+)
AMBER WARNING LAMP
RED STOP LAMP
SERVICE BRAKE RELEASED
FAN CONTROL #1
DIGITAL OUTPUT
DIGITAL OUTPUT
VEHICLE PWR SHUTDOWN
RESUME/ACCEL
CRUISE ENABLE
CLUTCH RELEASED
SENSOR SUPPLY #1
SENSOR SUPPLY #2
THROTTLE POSITION
VSG
IGNITION
IDLE VALIDATION
VEHICLE SPEED SENSOR (+)
VEHICLE SPEED SENSOR (-)
NO CONNECTION
NO CONNECTION
NO CONNECTION
AIR FILTER RESTRICTION
EXHAUST TEMPERATURE
SEO/DIAG REQUEST
A/C STATUS
ANALOG INPUT - 1.5kΩ PULLUP
TURBO COMPRESSOR IN TEMP
NO CONNECTION
EXHAUST BACK PRESSURE OR
FIRE TRUCK PUMP PRESSURE
NO CONNECTION
TACHOMETER
FREQUENCY - SPARE
FREQUENCY - SPARE
NO CONNECTION
NO CONNECTION
NO CONNECTION
ADD COOLANT LEVEL
COOLANT LEVEL - SHUTDOWN
ENGINE BRAKE LOW
OI ALARM
AUX SHUTDOWN #1
OI THERMOSTAT
J 1939 DL (+)
J 1939 DL SHIELD
NO CONNECTION
PWM OUTPUT
SET/COAST
ANALOG INPUT - 1.5kΩ PULLUP
FAN CONTROL OVERRIDE
PARK BRAKE
ENG BRAKE MED
PWM OUTPUT
ETHER START
OI STARTER
OI ACTIVE LAMP
J 1587 +
J 1587-
J 1939 DL (-)
SENSOR RETURN #2
SENSOR RETURN #1
+12V / +24V
+12V / +24V
BATTERY GROUND
BATTERY GROUND
+12V / +24V
+12V / +24V
BATTERY GROUND
BATTERY GROUND
LABEL
V-1
V-2
V-3
V-4
V-5
V-6
V-7
V-8
V-9
V-10
V-11
V-12
V-13
V-14
V-15
V-16
V-17
V-18
V-19
V-20
V-21
V-22
V-23
V-24
V-25
V-26
V-27
V-28
V-29
V-30
V-31
V-32
V-33
V-34
V-35
V-36
V-37
V-38
V-39
V-40
V-41
V-42
V-43
V-44
V-45
V-46
V-47
V-48
V-49
V-50
V-51
V-52
V-53
V-54
V-55
V-56
V-57
V-58
V-59
V-60
V-61
V-62
V-63
V-64
V-65
V-66
V-67
V-68
CAVITY
POWER WIRING
V-63
V-64
V-67
V-68
BATTERY (-)
BATTERY (-)
BATTERY (-)
BATTERY (-)
V-15
SWITCHED
IGNITION
BATTERY (-)
IGNITION
FUSE
BATTERY (+)
30 AMP
CAVITY
V-5
V-6
V-52
V-46
V-48
V-11
V-60
V-26
V-11
V-60
LABEL
LOW SIDE DIGITAL OUTPUT
LOW SIDE DIGITAL OUTPUT
PWM OUTPUT
PWM OUTPUT
INPUT
SENSOR SUPPLY #1*
INPUT WITH
1.5kΩ PULL-UP
SENSOR RETURN #1
CAVITY
SPARE DIGITAL & PWM OUTPUTS/INPUTS
DDEC V
VEHICLE INTERFACE HARNESS
68-WAY CONNECTOR
DDC P/N: 23528252
14 AWG TERMINAL
DDC P/N: 23528272
AUTOMOTIVE
LIMITING
SPEED
GOVERNOR
VARIABLE
SPEED
GOVERNOR
(OPTIONAL)
IDLE
VALIDATION
(REQUIRED)
ll information subject to change without notice. (Rev. 6/05)
7SA821 0506 Copyright © 2005 DETROIT DIESEL CORPORATION
55
40
25
16
1
10
41
45
30
56
60
15
68
61
64
26
11
65
46
31
INPUT
SENSOR SUPPLY #1*
INPUT WITH
1.5kΩ PULL-UP
SENSOR RETURN #1
* NOT USED FOR DIGITAL INPUTS
RESISTORS ARE INTERNAL TO ECU
V-16
V-59
IDLE VALIDATION
SENSOR RETURN #2
CAVITY
DASH PANEL
V-9
RETURN
SIGNAL
VEHICLE SPEED SENSOR
ON
OFF
ON
OFF
ON
OFF
ON
OFF
ON
OFF
CLUTCH
SWITCH
SET/COAST
SWITCH
RESUME/ACCEL
SWITCH
CRUISE
ENABLE
SWITCH
LABEL
CRUISE CONTROL
THROTTLE PEDAL
OPTIMIZED IDLE (OPTIONAL)
V-8
V-47
V-55
OI ACTIVE LAMP
+12/24V
V-54
OI STARTER
+12/24V
V-3
V-10
V-59
V-17
V-18
SENSOR RETURN #2
V-40
OI ALARM
V-42
OI THERMOSTAT
(REFER TO OPTIMIZED IDLE FOR RELAY REQUIREMENTS)
+12/24V
TO PIN D
OF
THERMOSTAT
CONNECTOR
V-24
V-59
INSTRUMENT PANEL
DIAGNOSTIC CONNECTOR
CAVITY
-
-
V-43
V-58
V-44
V-56
V-57
-
-
LABEL
GND
+12/24 V
J 1939 DATA LINK (+)
J 1939 DATA LINK (-)
J 1939 SHIELD
J 1587 DATA LINK (+)
J 1587 DATA LINK (-)
PLUG
PLUG
CAVITY
V-27
V-59
LABEL
DDC CONNECTOR
A
B
C
D
E
F
G
H
J
TURBO COMPRESSOR IN TEMP
MAINTENANCE ALERT SYSTEM ONLY
COACH APPLICATIONS ONLY
RED STOP LAMP
AMBER WARNING LAMP
IGN
IGN
+12/24V
FAN CONTROL - SINGLE SPEED FAN
LABEL
RSL
AWL
TACH OUTPUT
CAVITY
V-02
V-01
V-31
ENGINE BRAKE SWITCHES
DIAGNOSTIC REQUEST / STOP ENGINE OVERRIDE
A/C STATUS
FAN CTRL OVERRIDE
SENSOR RETURN
V-25
FAN CONTROL #1
V-4
V-49
V-59
CONNECTOR
DEUTSCH P/N: HD10-9-1939P
DDC P/N: 23529496
TERMINAL
DEUTSCH P/N: 0460-202-16141
DDC P/N: 23507132
DIAGNOSTIC REQ/
SEO SWITCH
V-11 SENSOR SUPPLY #1
AIR
FILTER
RESTRICTION
AIR FILTER RESTRICTION
SENSOR RETURN #1
V-22
V-60
A
B
C
V-60 SENSOR RETURN #1
FIRE TRUCK
PUMP
PRESSURE
SENSOR SUPPLY #1
PUMP PRESSURE
V-11
V-29
A
B
C
V-60 SENSOR RETURN #1
EXHAUST
BACK
PRESSURE
EXHAUST BACK PRESSURE
SENSOR SUPPLY #1
V-29
V-11
1
2
3
V-60 SENSOR RETURN #1
EXHAUST
TEMPERATURE
EXHAUST TEMPERATURE
V-23
A
B
TURBO
COMPRESSOR
IN TEMP
2
1
PARK BRAKE
SENSOR RETURN
V-59
V-50
ENG. BRAKE LOW
ENG. BRAKE MED
SENSOR RETURN
DIAG REQ/SEO
SENSOR RETURN
V-39
V-51
V-59
PARKING BRAKE & VEHICLE POWER SHUTDOWN
TCI
SENSOR RETURN #2
CAVITY
V-38
V-60
LABEL
ENGINE COOLANT LEVEL SENSOR - SHUTDOWN
COOLANT LEVEL
SENSOR
SHUTDOWN
A
B
COOLANT LEVEL
SENSOR RETURN
CAVITY
V-37
V-60
LABEL
ADD
COOLANT
LEVEL
A
B
ADD COOLANT LEVEL
SENSOR RETURN
CAVITY PLUG
DEUTSCH P/N: 114017
DDC P/N: 23507136
CONNECTOR COVER
DEUTSCH P/N: HDC16-9
DDC P/N: 23529497
18 AWG TERMINAL
DDC P/N: 23528271
+12/24V
DIGITAL OUTPUT
SERVICE BRAKE
SWITCH
IGN
VEHICLE POWER SHUTDOWN
V-7
SHROUD SIDE
OF CONNECTOR
To Next Page
Loading...