Emerson Rosemount 2460 System Hub

To Next Page

To Previous Page

Reference Manual

00809-0100-2460, Rev DE

Configuration

October 2018

Configuration

Figure 4-2. Rosemount Tank Gauging System Architecture with Redundant System Hubs

Rosemount 5900S

Radar Level Gauge

Host System

Field Ports

Rosemount 2410 Tank Hub

Rosemount 2240S

Temperature Transmitter

Rosemount 2230

Display

Modem

Host Ports

Rosemount 2460 System Hub

Backup

Redundancy cable

Host Ports

Rosemount 2460 System Hub

Primary

Main Page

Table of Contents5
Safety Messages13
Symbols14
Section Overview15
Technical Documentation16
Service Support17
Product Recycling/ Disposal17
Packing Material17
- Reuse and Recycling17
- Energy Recovery17
Introduction19
Communication20
Components21
- Enclosure24
- Write Protection Switch24
System Overview25
Installation Procedure32
Section Overview33
Safety Messages33
Installation Considerations35
- Installation Plan36
Mechanical Installation37
Electrical Installation40
- Cable Entries40
- Power Supply40
- Cable Selection for Power Supply40
- Grounding40
- Cabling for the TRL2/RS485 Bus41
- Connecting to a Rosemount 2460 System Hub42
- Wiring44
- Terminal Board and Ports45
- Ground Lug51
- Power Supply Connection52
- Wiring Diagrams54
Overview61
Safety Messages61
Setting up a Rosemount 2460 System Hub62
- Introduction62
- Installation Procedure62
- Preconditions for Redundancy Setup65
- Installation Wizard67
- Tank Databases of the Rosemount 2460 System Hub and the Rosemount 2410 Tank Hub7082
- System Setup87
- Redundancy Configuration88
- Redundancy Setup Via Web GUI92
Inventory Calculation Configuration95
- Inventory Manual Values99
- Rev de October100
Overview101
Safety Messages101
Light Emitting Diodes102
- Start-Up Procedure103
- Runtime Operation103
- Error LED104
- Status LED106
Redundancy Operation108
- Redundancy State109
- Errors and Warnings111
- Manual Switch over113
Safety Messages116
Tools117
Troubleshooting117
Exchanging a Modem Card120
Exchanging the Terminal Board122
Replacing the Power Supply Unit124
Using the Web Interface126
Ports Statistics129
Logging130
- To Stop Logging132
- Downloading Log Files to a PC133
Modbus TCP Configuration135
User Defined Modbus136
Modbus TCP Statistics137
Ports138
- Protocol Options138
- Type Options138
- I-Reg Mapping Options138
Network139
- Recommendations for Modbus TCP IP Addressing140
Diagnostics141
Restore to Factory Defaults142
Configuration Backup143
- Configuration Backup Using Winsetup144
Configuration Recovery145
- Configuration Recovery Using Winsetup146
Firmware Upgrade147
- Firmware Upgrade of a Single Rosemount 2460 System Hub147
- Firmware Upgrade of Redundant System Hubs148
License Upgrade149
- Upgrade Procedure149
Redundancy152
- Pairing Two System Hubs152
- To Unpair Redundant System Hubs153
Fuses154
Write Protection155
- Hardware Write Protection Switch155
- Software Write Protection156
Replacing the Backup Battery157
Setting the Real-Time Clock158
Maintenance159
Modem Cards160
- RS232 and RS485160
- Enraf162
- L&J163
- Varec164
- Modem Multi Loop165
A.1 Communication/Configuration Specifications167
- A.1.5 Enraf Emulation168
- A.1.12 Digital Communication Protocols169
A.2 Electrical Specifications172
A.6 Dimensional Drawings173
A.7 Ordering Information175
B.1 European Directive Information181
B.2 Ordinary Location Certification181
B.3 Telecommunication Compliance181
- B.3.1 FCC and IC181
Tank Database Configuration for Enraf Devices183
Advanced Enraf Configuration186
- Fast Polling186
- Configure Vapor Temperature186
Sending a Servo Command187
Servo States191
Type of Request (TOR)192
Tank Database Configuration193
Advanced Whessoe Configuration196
- Fast Polling196
- Configure Range Values for Whessoe WM550196
- Configure Vapor Temperature for Whessoe WM660198
Introduction199
- Priority199
FC02 Status Register Area200
- Tank Register Area200
FC03 Register Area202
- System Register Area202
FC04 Register Area203
- Tank Register Area203
- System Register Area209
- Inventory Register Area210
User Defined Modbus Mapping211
Configure Fast Polling with Common Threshold216
Configure Fast Polling with Individual Thresholds218
Tank Database Configuration221
Advanced L&J Configuration224
- Fast Polling224
Tank Database Configuration225
Advanced Varec Configuration228
- Fast Polling228
858 CIU Configuration231
Introduction231
Getting Started232
Host Port Configuration233

Emerson Rosemount 2460 System Hub - Page 66

Table of Contents

Related product manuals