I–2
INDEX
Pressure Relief Valve 192, 197
Thermostat 11, 192
Turbulence 39
Vapor Separator 159
Water Intake Screens 68, 69, 271, 281
Water Pump 191, 263
Water Supply Tube 191, 241, 243
Corrosion
Anodes 67, 247, 250, 267, 278
Cylinder walls 210
Long Term Storage 77
Metal components 67
Steering Cable 69
Cover Service 82
Crankcase
Assembly 221
Disassembly 205
Crankshaft
Assembly 213, 218
Disassembly 207
Inspection 211
Crankshaft Position Sensor
Description 91
Operation Test 110
Resistance Test 124
Cylinder Bore
Honing 210
Inspection 211
Cylinder Head
Inspection 211
Installation 217
Removal 206
D
nnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn
Dash Connections 120
Deutsch Connector Servicing 148
Diagnostic Procedures
Dynamic Tests 106
Fuel Delivery Tests 114
Ignition Tests 109
LED Indicators 107
Strategy 104
Diagnostic Software
Break-In Programming 54, 57, 182
CANbus Activation 50
Communication with Outboard 95
Crankshaft Position Sensor 110
Cylinder Drop Tests 106
Fuel Injector Programming 100, 169
Fuel Pump Test 114
Idle Speed Control 99
Oil Injector Test 183
Oil Priming 54, 187
Oiling Rate 53, 54, 98
Reports 100
Sensor Monitoring 124
Service Codes 96
Static Ignition Test 111
Timing Verification 99, 143
TPS Calibration 99, 143
Driveshaft
Installation 283
Removal 268
Service 270
Shimming 280
Driveshaft Bearing Housing 277
Dual-Outboard
Alignment 63
CANbus Setup 50
Centerlines 40
E
nnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn
Electrical Circuits
EMM Pin Locations 121
Fuse 123
Ground Circuits 123
Key Switch 131
Start Circuit 129
SystemCheck 136
Electrical Connectors 148
AMP Connectors 149
Deutsch Connectors 148
Packard Connectors 151
Electrical Harness
Rigging 48
To Next Page
Loading...
Need help?
General
