Ford FUSION HYBRID - Page 11

FCS-15129-13 2013 Fusion MKZ Hybrid Emergency Response Guide
9
ENERGI COMPONENT LOCATION AND IDENTIFICATION - CONTINUED
COMPONENT
LOCATION / DESCRIPTION
FUNCTION
2 High-Voltage Battery
Approximately 300
Volts DC
• Lies flat in the trunk area,
located behind the rear seat.
• Sealed lithium battery.
Provides high-voltage storage
for vehicle’s electric motor.
4 12-Volt Battery
• Located in the trunk area of
the vehicle.
• Typical automotive 6-cell
lead/acid design.
Provides 12-volts for vehicle
accessories.
1 High-Voltage
Service Disconnect
• Orange rectangle with a
molded plastic handle, about
100 mm (4 in) in length.
Provides means to disconnect
high-voltage battery for safely
servicing vehicle.
5 High-Voltage Wiring
• Runs along the vehicle’s
floorpan from the high-voltage
battery to the Electronically
Controlled Continuously
Variable Transaxle (ECVT),
to the DC-to-DC converter
and then to the electric A/C
and heater units.
Provides physical connection
between High-Voltage battery
and vehicle’s High-Voltage
equipment.
8 Electronically
Controlled
Continuously
Variable Transaxle
(ECVT)
• Transverse-mounted design,
similar to the non-Hybrid
Fusion MKZ vehicles.
Provides rotational force to the
wheels for vehicle propulsion and
transmits rotational force to the
engine’s generator to recharge
batteries.
Provides 110v charging option to
the high-voltage battery when the
vehicle is not in operation .
9 Electric A/C
Compressor
• Located in front of the
engine.
• It has an orange high voltage
wire attached to it using an
interlock connector.
Provides electric A/C operation;
replaces the belt driven A/C
compressor.
• Located behind the rear
seat back.
• All high-voltage wiring has
orange-colored insulation.
6 Charging Port
• Located on the driver side
fender.
7 Transmission
Control Module
• Contains controlling
electronics for managing
propulsion.
• Located above the
transmission.
Provides rotational force during
Electrical Drive Modes. Gener-
ates 3-phase AC High Voltage
electricity via two cables to and
from the traction motor and
generator.
10 Electric Heater
• Located in the engine
compartment on the
passenger side.
Provides passenger compart-
ment with heat without the need
to turn the engine on.
3 110-Volt Cordset
• Located in the trunk area of
the vehicle.
Provides 110v charging option to
the high-voltage battery when
connected to the charging port .