Home
Generac Power Systems
Portable Generator
38 kW
Generac Power Systems 38 kW User Manual
5
of 1
of 1 rating
60 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Maintenance
Owner
’s Manual for S
tationary Emergency Generators
35
Figure 5-8. Oil Drain Hose, Fi
ll Cap, Dipstick and Filter
A
B
40
42
Table of Contents
Default Chapter
3
Table of Contents
3
Section 1 Safety
7
Introduction
7
Safety Information
8
General Hazards
8
Exhaust Hazards
9
Electrical Hazards
9
Fire Hazards
9
Explosion Hazards
9
Section 2 Specifications
11
Emission Information
11
Emissions Data Plate
11
Specifications
12
Engine Oil Recommendations
13
Weather and Maintenance Kits
14
Coolant Water Treatment
14
Fuel Requirements
14
Reconfiguring the Fuel System
15
Fuel Conversion Procedure from NG to LPV
15
Change Fuel Selection
16
Battery Requirements
16
Battery Charger
16
Corrosion Protection
16
Section 3 Activation and Startup
17
Orientation
17
Remove Side Access Panels
17
Install Battery
18
Open Viewing Window
18
Activate Unit
19
Start and Run Engine
20
Operational Checks
21
Self Test
21
Check Manual Transfer Switch Operation
21
Electrical Checks
21
Test Generator under Load
22
Check Automatic Operation
22
Final Instructions
23
Section 4 Operation
25
Control Panel
25
Auto/Manual/Off
25
Menu Navigation
26
Alarm/Warning Conditions
29
Change Time and Date
29
Programmable Timers
29
Dealer Programmable
29
Exercise Time
29
User Programmable
30
Start-Up Delay Timer
30
Warm-Up Delay Timer
30
USB Port for Firmware Updates
30
Battery Charger
30
Transfer Switch Automatic Operation
30
Automatic Sequence of Operation
31
Utility Failure
31
Cranking
31
Load Transfer
31
Transfer Switch Manual Operation
31
Transfer to Generator Power
32
Transfer Back to Utility Power
32
Section 5 Maintenance
33
Component Locations
33
Access Panels
34
Removal
34
Installation
34
Service Maintenance Intervals
35
Remove from Service
36
Hour Break-In
36
Daily Maintenance
36
Schedule a Maintenance
37
Schedule a Maintenance Item Locations
37
Preliminary Instructions
37
Check Enclosure Louvers
37
Check Fuel Lines
37
Check Coolant Level and Hoses
38
Check Radiator for Clogging
38
Check Lubricating Oil Level and Drain Hose
38
Replace Lubricating Oil and Oil Filter
39
Check Battery Condition/Fluid Level
43
Check Condition and Clean
43
Check Fluid Level
43
Check State of Charge
43
Battery Replacement
43
Check and Adjust Accessory/Drive Belt
44
Check
44
Adjust
44
Replace Air Filter Element
45
Final Instructions
46
Schedule B Maintenance
47
Schedule B Maintenance Item Locations
47
Drain/Flush Coolant System
47
Clean/Gap/Replace Spark Plugs
48
Final Instructions
49
Schedule C Maintenance
50
Return to Service
50
Lube Oil Maintainer System
51
Description
51
Fill Oil Supply Tank
51
Test Functionality
52
Shutoff Valve
52
Section 6 Troubleshooting
53
Engine Troubleshooting
53
Controller Troubleshooting
54
Removal from Service During Utility Outages
55
Storage
55
Prepare for Storage
55
Return from Storage
56
Attention after Submersion
57
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Generac Power Systems 38 kW and is the answer not in the manual?
Ask a question
Generac Power Systems 38 kW Specifications
General
Brand
Generac Power Systems
Model
38 kW
Category
Portable Generator
Language
English
Related product manuals
Generac Power Systems 30 kW
60 pages
Generac Power Systems 32 kW
60 pages
Generac Power Systems 9 kW
40 pages
Generac Power Systems 22 kW
60 pages
Generac Power Systems 27 kW
60 pages
Generac Power Systems 60 kW
60 pages
Generac Power Systems 7 kW NG
210 pages
Generac Power Systems 20 kW LP
210 pages
Generac Power Systems 16 kW NG
210 pages
Generac Power Systems 17 kW LP
210 pages
7 kW PowerPact
36 pages
PowerPact 7.5 kW
96 pages
Need help?
General
To Next Page