Golight Radioray 2000

To Next Page

IMPORTANT SAFETY INFORMATION

 This symbol is to alert you to important operating or servicing

instructions that appear in your instructions. Always follow

basic safety precautions when using this product to reduce

the risk of injury, fire or electric shock.

 This light is for off road and utility use only. It is not de-

signed for road use as a driving light.

 The RadioRay® complies with Part. 15 of the FCC Rules.

Operation is subject to the following two conditions: (1) This

light and remote may not cause harmful interference, and (2)

this light and remote must accept any interference received,

including interference that may cause undesired operation.

 FCC RULE Part. 15.21 - Changes or modiﬁcations made by

the user not expressly approved by Golight, Inc. for compli-

ance could void the user’s authority to operate the equip-

ment.

For safe and efﬁcient operation of your Golight® RadioRay®,

observe these guidelines:

Using your RadioRay® in icing conditions could damage the gear

motors.

The remote must be kept clean and dry to avoid damage to the

internal circuitry.

Your Golight® RadioRay® is a radio transmitter and receiver

operating at 433MHz. Whenever the light is on, the internally

mounted antenna sends out and receives radio frequency (RF)

energy.

• Modern electronic equipment, i.e. Personal medical devices

such as pacemakers, hearing aids, etc., are shielded from RF

energy. However, RF energy may affect some electronic equip-

ment.

• Vehicle electronic systems may be affected by RF energy.

Check with your vehicle manufacturer representative to be

sure that your RadioRay® will not affect the electronic system

of your vehicle.

HALOGEN BULB REPLACEMENT / PARTS / ACCESSORIES

The Golight® RadioRay® utilizes a Philips® H-9 bulb, which may

be purchased through Golight, Inc. along with other parts and

accessories. Visit our web store at: http://store.golight.com or

THREE YEAR LIMITED WARRANTY

Golight, Inc. warrants the RadioRay® against any deemed defects

that are due to workmanship for parts or faulty materials, except

halogen lamps, for three years from the date of the original

purchase. This warranty to the RadioRay® does not cover damage

resulting from unreasonable use or misuse, unreasonable

maintenance or loss, or labor costs.

Mounting the light upside down will void the warranty.

Warranty information must be ﬁlled out within 30 days of purchase

at: http://golight.com/products/registration.html, for warranty

protection.

If the Golight® RadioRay® does fail to operate under warranted

speciﬁcations, send the light and remote controls postage paid,

plus $9.95 for shipping and handling to: Golight, Inc. • Service

Department • 37146 Old Hwy 17 • Culbertson, NE 69024-8226.

No C.O.D.’s accepted. Only the above manufacturer is authorized

to perform warranty repair or replace product.

Any consequential damages to person or property are excluded

from this warranty. Some states do not allow the exclusion and

limitation of incidental or consequential damages, therefore the

above limitations or exclusions may not apply to you. This war-

ranty gives you speciﬁc legal rights and you may also have other

rights.

End of Useful Life

For information regarding the proper disposal/recycling of the light

contact Golight at 800.557.0098

Golight Inc

37146 Old Hwy 17

Culbertson, NE 69024

800.557.0098 | 308.278.3131

www.golight.com | info@golight.com

MODEL NUMBERS: 2000, 2051, 20004, 20514

Instruction Guide

Congratulations

You are now the owner of one of the ﬁnest remote control

searchlights available today. Thank you for letting Golight®

assist you in your lighting application needs. We’re proud

of our products and the technology that we’ve developed to

ensure our customers the most durable, versatile and powerful

searchlights in the lighting industry.

Please read these instructions before using your new Golight®

Radioray®.

Need help?

Do you have a question about the Golight Radioray 2000 and is the answer not in the manual?

The Golight® RadioRay® is a sophisticated remote-controlled searchlight designed for off-road and utility use, offering advanced lighting capabilities and robust construction. This device is engineered for permanent attachment to a vehicle or boat, providing a powerful and versatile lighting solution.

Function Description

The primary function of the Golight® RadioRay® is to provide directional illumination through a remote-controlled searchlight. It allows the operator to precisely control the light's direction, making it ideal for various off-road and utility applications where a fixed light source might be insufficient. The system comprises a searchlight unit and a wireless remote control, enabling flexible operation from a distance. The light is designed to be mounted externally on a vehicle or boat, ensuring optimal beam movement and coverage.

Important Technical Specifications

The Golight® RadioRay® is available in several models, including 2000, 2051, 20004, and 20514. It features a 2-speed searchlight with directional flexibility. Rotation and Tilt: The searchlight offers a full 370° horizontal rotation and a 135° vertical tilt, controlled with fingertip precision. The light can rotate approximately 185° to the left and 185° to the right from its normal forward direction. Vertically, the beam can angle down about 45° and up to 90°. Light Source: The RadioRay® utilizes either Cr5 PentaBeam™ technology in a halogen configuration or state-of-the-art P-Vex™ lens and LED technology. For halogen models, it uses a Philips® H-9 bulb. Power Requirements: The device operates on 12 Volt DC power. It is not polarity sensitive and requires a 10 Amp fuse on a dedicated circuit or an appropriate automotive relay system. Remote Control: The wireless remote control operates at 433MHz and offers 2187 different programmable channels, allowing users to change channel selections to avoid interference. The remote has a range of up to 80 feet, depending on conditions. It is powered by two A23 12V batteries. Compliance: The RadioRay® complies with Part 15 of the FCC Rules, meaning it must not cause harmful interference and must accept any interference received. Durability: The device is built for durability, with a three-year limited warranty covering defects due to workmanship or faulty materials, excluding halogen lamps. Mounting the light upside down will void the warranty.

Usage Features

Remote Control Operation: The light is turned on and off using the on/off button on the remote. Directional control is achieved via 4-way arrows on the remote. Speed Control: The speed of the light's rotation can be adjusted using the tortoise/hare button on the remote, allowing for precise or rapid movement. Mounting: The searchlight is designed for permanent mounting. The base includes a small arrow indicating the normal forward direction. A black rubber gasket is used as a footprint for marking mounting holes. A 1/4-inch hole is required for the power cord, with silicone sealant recommended to seal the opening. It is crucial to leave 3 inches of cord under the light to ensure full 370° rotation. Screw or bolt fasteners appropriate to the mounting surface should be used. For covering screw heads, #8 round head screws are recommended with the provided plastic caps. The black gasket should be installed on the lamp base, with its small drain hole facing opposite the vehicle's forward direction. Silicone or other sealants should not be used around the base gasket, as this can impede proper water drainage. Programmable Remote: The remote control can be programmed to avoid outside interference. This involves disconnecting power, removing the battery cover, setting 7 dip switches to a desired position (positive, negative, or neutral), inserting batteries, and then performing a sequence of button presses while reconnecting power. Included Components: Each RadioRay® unit includes the searchlight, a wireless remote control, two A23 12V batteries, a permanent mounting gasket, and a rockguard (not applicable for LED units).

Maintenance Features

Bulb Replacement: For halogen models, the Philips® H-9 bulb can be replaced. Replacement bulbs and other parts are available through Golight, Inc. Battery Replacement: The remote control batteries (two A23 12V batteries) need to be replaced when depleted. This involves removing a phillips head screw to access the battery compartment. Only 12V-A23 batteries should be used. Information regarding proper disposal/recycling of batteries is available from Golight. Warranty Service: In case of warranted failure, the light and remote controls should be sent to Golight, Inc. Service Department, postage paid, with a $9.95 shipping and handling fee. Only the manufacturer is authorized to perform warranty repair or replace the product. Care and Precautions:

The remote control must be kept clean and dry to prevent damage to its internal circuitry.
Operating the RadioRay® in icing conditions could damage the gear motors.
The spotlight should not be turned on when the snap-on lens cover (rockguard) is attached (not applicable for LED models).
The device is intended for off-road and utility use only and should be mounted outside the vehicle.
It is not approved for road or highway use, underwater use, or inverted mounting.
It should not be used inside a vehicle or enclosure unless power is removed prior to placement.
The light may only be disassembled and repaired by an authorized representative. Any violation of these guidelines will void the warranty.
The RadioRay® emits RF energy at 433MHz. While modern electronic equipment is typically shielded, users should check with their vehicle manufacturer to ensure the RadioRay® will not affect vehicle electronic systems or personal medical devices like pacemakers or hearing aids.

End of Life: For information regarding proper disposal and recycling of the light, users should contact Golight.