HABCO SE40eHC - Meanings of Signal Words and Symbols; Energy Efficiency Tips; Glossary

HABCO® TECHNICAL DOCUMENT - C098791 • 10310209
© HABCO Manufacturing Inc. “HABCO, Cassette, Cold Space Merchandiser” are registered trademarks of HABCO Manufacturing Inc. Domestic and International Patents. Page 2
HABCO® COMMERCIAL REFRIGERATORS-CASSETTE®
SAFETY, INSTALLATION AND INSTRUCTION MANUAL
CABINET MODELS: SE18, SE24, SE28, SE40e, SE42, SE46

HABCO Management Systems are Cered to ISO 9001-2015
IMPROPER OR UNSAFE use of this appliance other than intended by
the manufacturer, can result in death, serious bodily injury, property
damage and/or appliance damage!
This manual contains important informaon about product safety.
Read and understand this manual BEFORE operang the appliance.
Please keep this manual available for other users and owners before
they use the appliance. Store this manual in a secure locaon.
WARNING
DANGER: RISK OF FIRE OR EXPLOSION. FLAMMABLE REFRIG-
ERANT USED. TO BE REPAIRED ONLY BY TRAINED SERVICE PER-
SONNEL. DO NOT USE MECHANICAL DEVICES TO DEFROST RE-
FRIGERATOR. DO NOT PUNCTURE REFRIGERANT TUBING. R290
REFRIGERATION SYSTEM (CASSETTE) SHOULD ONLY BE USED IN
A HABCO UNIT THAT IS DESIGNED AND APPROVED FOR R290.
INTENDED USE
HABCO® Commercial Refrigerators are designed for the commercial
refrigerated storage and display. Not intended for use in outdoor, di-
rect sun, damp, extreme heat and/or cold condions.
MEANINGS OF SIGNAL WORDS AND SYMBOLS
WARNING indicates potenally hazardous situaons which,
if ignored, could result in death or serious injury.
WARNING indicates potenally hazardous situaons which,
if not avoided, may result in minor or moderate injury.
NOTICE emphasizes essenal informaon or that which may
cause appliance damage or environmental harm.

Secon Subject Page
INFORMATION AND TABLE OF CONTENTS ......................2
SAFETY .............................................................................3
A. INSPECTION & UNPACKING ............................................4
B. LOCATION ........................................................................4
C. ELECTRICAL ......................................................................4
D. START-UP ......................................................................... 5
E. THERMOSTAT LOCATION & ADJUSTMENT .......................5
F. LIGHTING ......................................................................... 6
G. CASSETTE® ACCESS & REMOVAL .....................................6
H. DOORS ............................................................................. 7
Easy Mount Swing Door Reversal ....................................7
Sliding Door Removal and Adjustment ............................8
I. PREVENTATIVE MAINTENANCE .....................................10
J. CLEANING PROCEDURES ...............................................10
K. TROUBLE-SHOOTING .....................................................12
ENERGY EFFICIENCY TIPS
HABCO® Commercial Refrigerators bearing the ENERGY STAR® logo are
manufactured and designed to perform within the most stringent en-
ergy efficiency guidelines. The following energy efficiency tips, however,
pertain to all commercial refrigerators and should be followed for best
energy efficiency results.
1. Maintain a clean condenser coil.
2. Turn off lighting when not in use.
3. Maintain clean door seals and ensure bottom door guide is
clear of debris at all times.
4. Do not install in direct vicinity of high heat or high humidity
sources such as heating vents, baseboard heaters, ranges,
and ovens, steam cookers, commercial dishwashers.
5. Do not install directly beneath undiffused air conditioning
vents.
6. Read, understand and observe Safety Warnings and Notices
in this manual as many of these points will also contribute
to energy savings and appliance efficiency.

Term Explanaon/Alternate Term
Commercial Refrigerator Appliance
Cassee® Self-Contained, Removable Refrigeraon Package
Compressor Refrigerant Compressing Motor Mounted to Front of Cassee®
Evaporator (Coil) Cooling Coil Mounted to Rear of Cassee®
Free&Clear™, Finless Condenser (Coil) Finless, Circular Formed Heat Exchange Coil Mounted to Front of Cassee®
Cassee® Chamber Refrigeraon Enclosure
Evaporator Chamber Cooling Coil Enclosure Located within Cassee® Chamber
Mechanically Fastened Areas Areas Requiring a Tool to Access
Trained Professional Trained Refrigeraon and/or Electrical Contractor
Owner Person or Company Holding Legal Title to Appliance
Header Upper Front Metal Panel