COMPONENT MAINTENANCE MANUAL
1152682
Page B-1
Oct 27/06
© Honeywell International Inc. Do not copy without express permission of Honeywell.
23-24-02
APPENDIX B
MATERIAL SAFETY DATA SHEET (MSDS)
TABLE B-1. MATERIAL SAFETY DATA SHEET – BATTERY PACK P/N 1096801-1
SECTION 1 – Product Identification and Use SECTION 3 – Hazards Identification
Product:
Lithium Manganese Dioxide Primary Cells and Batteries
(Li-MnO
2
)
Identifier: Ultralife “D” Cell 3 Volt
Product Identification Number (PIN): U3356
Manufacturer Name:
Ultralife Batteries, Inc.
2000 Technology Parkway
Newark, NY 14513-2175
USA
Phone: USA 1-800-424-9300
International: 703-527-3887
Supplier’s Name: as above
PREPARED BY: Jennifer Dimock
DATE: September 20 2005
EMERGENCY OVERVIEW:
May leak and/or flame if opened, recharged, connected
improperly, or disposed of in fire.
POTENTIAL HEALTH EFFECTS:
Skin contact may cause irritation and absorption.
Contact with raw lithium may cause burns.
Routes of entry: Inhalation or ingestion of electrolyte may
have toxic effects.
Acute exposure: Electrolyte may irritate skin and eyes.
Effects of chronic exposure: Electrolyte contains a
teratogen.
SECTION 2 – Composition/Information on
Ingredients
SECTION 4 – First Aid Measures
ELECTROLYTE CONTACT:
Skin:
Immediately flush with plenty of water for a minimum of 15
minutes. If symptoms are present after flushing, get medical
attention.
Eyes:
Immediately flush with plenty of water for a minimum of 15
minutes and get medical attention.
LITHIUM METAL CONTACT:
Skin:
Remove particles of lithium from skin as rapidly as possible.
Immediately flush with plenty of water for a minimum of 15
minutes and get medical attention.
Eyes:
Immediately flush with plenty of water for a minimum of 15
minutes and get immediate medical attention.
Chemical Name CAS # Exposure Limits
Percent of
Content
Manganese Dioxide,
MnO
2
1313-13-9 None Listed 40-45
Lithium Metal, Li 7439-93-2 None Listed 3-4
Propylene
Carbonate, C
4
H
6
O
3
108-32-7 None Listed 4-5
Ethylene Glycol
Dimethyl Ether,
C
4
H
10
O
2
Shipping Name: 1,2-
Dimethoxyethane
110-71-4 5 ppm TWA
1 ppm Pregnant
Women
3-4
Tetrahydrofuran,
C
4
H
8
O
109-99-9 200 ppm TWA 3-4
Lithium Perchlorate,
LiClO
4
7791-03-9 None Listed 1
NOTE: The materials in this section may only represent a
hazard if the integrity of the battery is compromised or if
the battery is physically or electrically abused.
To Next Page
Loading...
