Husky Trim-Plus H1503TP-R - Daily Tank Draining Procedure; Safety Valve Inspection Method

15
/0%2!4)/.
$2!).).'4(%4!.+
3EE&IGURE
4OHELPPREVENTTANKCORROSIONANDKEEPMOISTUREOUT
OFTHEAIRUSEDTHETANKOFTHECOMPRESSORSHOULDBE
DRAINEDDAILY
4ODRAIN


 
 +EEPTHECOMPRESSORTILTEDUNTILALLMOISTUREHAS
BEENREMOVED
 (OLDINGTHEHANDLETILTTHECOMPRESSORTOWARDTHE
DRAINVALVESOTHATITSSETINALOWERPOSITION


$RAINMOISTUREFROMTANKINTOASUITABLECONTAINER
 ./4% #ONDENSATEISAPOLLUTINGMATERIALANDSHOULDBE
DISPOSEDOFINCOMPLIANCEWITHLOCALREGULATIONS
 )FDRAINVALVEISCLOGGEDRELEASEALLAIRPRESSUREREMOVE
ANDCLEANVALVETHENREINSTALL
7!2.).'
5NPLUGTHEAIRCOMPRESSORANDRELEASEALLAIRFROM
THETANKBEFORESERVICING&AILURETODEPRESSURIZETANK
BEFOREATTEMPTINGTOREMOVEVALVEMAYCAUSESERIOUS
PERSONALINJURY
4URNOFFDRAINVALVEUNTILCOMPLETELYCLOSED
#(%#+).'4(%3!&%496!,6%
3EE&IGURE
$!.'%2
$ONOTATTEMPTTOTAMPERWITHTHESAFETYVALVE!NY
THINGLOOSENEDFROMTHISDEVICECOULDFLYUPANDHIT
YOU&AILURETOHEEDTHISWARNINGCOULDRESULTINDEATH
ORSERIOUSPERSONALINJURY
4HESAFETYVALVEWILLAUTOMATICALLYRELEASEAIRIFTHEAIR
RECEIVERPRESSUREEXCEEDSTHEPRESETMAXIMUM4HEVALVE
SHOULDBECHECKEDBEFOREEACHDAYOFUSEBYPULLINGTHE
RINGBYHAND
 4URNTHEAIRCOMPRESSORONANDALLOWTHETANKTOFILL
4HECOMPRESSORWILLSHUTOFFWHENTHEPRESSUREREACH
ESTHEPRESETMAXIMUM
 4URNTHEAIRCOMPRESSOROFF
 0ULLTHERINGONTHESAFETYVALVETORELEASEAIRFORT 
SECONDS
 2ELEASETHERING!IRMUSTIMMEDIATELYSTOPESCAPING
WHENTHERINGISRELEASED!NYCONTINUEDLOSSOFAIR
AFTERRELEASINGTHESAFETYVALVERINGINDICATESAPROBLEM
WITHTHESAFETYVALVE$ISCONTINUEUSEANDSEEKSERVICE
BEFORECONTINUEDUSEOFTHEAIRCOMPRESSOR
&IG
&IG
3!&%49
6!,6%
$2!).
6!,6%
7!2.).'
)FAIRLEAKSAFTERTHERINGHASBEENRELEASEDORIFTHE
VALVEISSTUCKANDCANNOTBEACTUATEDBYTHERING$O
.OTUSETHEAIRCOMPRESSORUNTILTHESAFETYVALVEHAS
BEENREPLACED5SEOFTHEAIRCOMPRESSORINTHISCONDI
TIONCOULDRESULTINSERIOUSPERSONALINJURY
&I
SAFETY
VALVE
DRAIN VALVE
&IG
&IG
3EE&IGURE
3EE&IGURE
&IG
SAFETY
VALVE
DRAIN VALVE
&IG
&IG
3EE&IGURE
3EE&IGURE
&IG
SAFETY
VALVE
DRAIN VALVE
&IG9
&IG8
3EE&IGURE8
3EE&IGURE9
2ELEASETHERING!IRWILLSTOPESCAPINGWHENTHERING
ISRELEASEDATAPPROXIMATELYPSI!NYCONTINUEDLOSS
OFAIRAFTERRELEASINGTHESAFETYVALVERINGINDICATESA
PROBLEMWITHTHESAFETYVALVE$ISCONTINUEUSEANDSEEK
SERVICEBEFORECONTINUEDUSEOFTHEAIRCOMPRESSOR
)FAIRLEAKSBELOWPSIAFTERTHERINGHASBEENRELEASED
ORIFTHEVALVEISSTUCKANDCANNOTBEACTUATEDBYTHE
RING$O.OTUSETHEAIRCOMPRESSORUNTILTHESAFETY
VALVEHASBEENREPLACED5SEOFTHEAIRCOMPRESSORIN
THISCONDITIONCOULDRESULTINSERIOUSPERSONALINJURY
Fig. 8
DRAIN VALVE
DRAIN VALVE
SAFETY VALVE
Fig. 9
If drain valve is clogged, release all air pressure by pulling
the safety valve. Remove and clean valve, then reinstall.
SAFETY VALVE
If drain valve is clogged, release all air pressure by pulling
the safety valve. Remove and clean valve, then reinstall.
Fig. 9
Fig. 8
DRAIN VALVE