Husqvarna TS 348XD - FUSE, HOOD, AND HEADLIGHT REPLACEMENT

26
Fig. 42
SERVICE AND ADJUSTMENTS
REPLACING BATTERY (See Fig. 43)
WARNING: Do not short battery termi-
nals by allowing a wrench or any other
object to contact both terminals at the
same time. Before connecting battery,
remove metal bracelets, wristwatch
bands, rings, etc. Positive terminal
must be connected first to prevent
sparking from accidental grounding.
• Lifthoodtoraisedposition.
• Removeterminalcover.
• DisconnectBLACKbatterycable then RED battery
cable and carefully remove battery from tractor.
• Installnewbatterywithterminalsinsamepositionas
old battery.
• Reinstallterminalcover.
• FirstconnectREDbatterycabletopositive(+)battery
terminal with bolt and nut as shown. Tighten securely.
• ConnectBLACKgroundingcabletonegative(-)battery
terminal with remaining bolt and nut. Tighten securely
• Closehood.
Fig. 43
TO REMOVE HOOD AND GRILL ASSEMBLY
(See Fig. 45)
• Raisehood.
• Unsnapheadlightwireconnector.
• Standinfrontoftractor.Grasphoodatsides,tilttoward
engine and lift off of tractor.
• Toreplace,reverseaboveprocedure.
Fig. 45
TRANSMISSION
REMOVAL/REPLACEMENT
Should your transmission require removal for service or
replacement,itshouldbepurgedafterreinstallationand
beforeoperatingthetractor.See“PURGETRANSMISSION”
intheOperationsectionofthismanual.
ENGINE
TO ADJUST THROTTLE CONTROL CABLE
The throttle control has been preset at the factory and
adjustmentshouldnotbenecessary.Ifadjustmentisnec-
essary,seeenginemanual.
TO ADJUST CHOKE CONTROL
Thechokecontrolhasbeenpresetatthefactoryandadjust-
mentshouldnotbenecessary.Ifadjustmentisnecessary,
see engine manual.
07002
HEADLIGHT WIRE
CONNECTOR
HOOD
TO REPLACE HEADLIGHT BULB
• Raisehood.
• Pullbulbholderoutoftheholeinthebacksideofthe
grill.
• Replacebulbinholderandpushbulbholdersecurely
back into the hole in the backside of the grill.
• Closehood.
INTERLOCKS AND RELAYS
Looseordamagedwiringmaycauseyourtractortorun
poorly,stoprunning,orpreventitfromstarting.
• Checkwiring.
Fig. 44
TO REPLACE FUSE (See Fig. 44)
Unit has two automotive type fuses.  Replace primary
operation fuse with a 20 amp and the differential lock
actuatorfusewitha10amp.Thefuseholdersarelocated
behind the dash.
02954
POSITIVE
(RED)
CABLE
TERMINAL
COVER
NEGATIVE
(BLACK)
CABLE
WEAK OR DEAD
BATTERY
FULLY CHARGED
BATTERY