IDEAL Mexico RS 3/100 - Introduction to Mexico Super RS Boilers; Optional Extra Kits

4
Mexico Super RS 3/100 & 3/125 - Installation
INTRODUCTION
Mexico Super RS above range is of floor standing,
natural draught, balanced flue gas boilers. They are
range-rated to provide central heating outputs of 23.4 kW
(80,000 Btu/h) to 35.8 kW (122,000 Btu/h).
The boiler has a cast iron heat exchanger and is supplied
fully assembled, complete with a white enamelled mild
steel casing.
A door at the top of the casing front panel hinges down,
revealing the boiler thermostat control (and programmer,
if fitted).
The boilers are suitable, as standard, for connection to
open-vented systems ONLY - an overheat thermostat kit
is available to allow the boiler to be used on sealed water
systems.
The systems may be:
z pumped or gravity circulating indirect DHW only
z pumped central heating only
z pumped central heating combined with either a
pumped or gravity circulating indirect DHW circuit.
OPTIONAL EXTRA KITS
Programmer Kit Fits neatly within the casing. Separate
fitting instructions are included with this kit.
Pump Kit Fits neatly within the casing. Separate
fitting instructions are included with this kit.
Overheat is available to allow the boiler to be used
Thermostat Kit on sealed water systems.
CONTENTS
Air Supply. ..................................................................... 7
Boiler Assembly - Exploded view ................................ 9
Boiler Clearances .......................................................... 6
Burner Assembly - Exploded view ............................ 30
Electrical Connections ............................................... 15
Electrical Diagram ....................................................... 16
Electrical Supply ........................................................... 8
Extension Ducts - Fitting ............................................ 13
Fault Finding ................................................................ 28
Flue Fitting ................................................................... 13
Flue Installation ............................................................. 7
Gas Safety Regulations ................................................ 5
Gas Supply .................................................................... 7
Initial Lighting .............................................................. 19
Installation ..................................................................... 9
Mandatory Requirements ............................................. 5
Pump ............................................................................ 14
Servicing ...................................................................... 21
Short List of Parts ....................................................... 29
System Electrical Diagrams ....................................... 17
Terminal Guards. ........................................................... 7
Terminal Sizes. .............................................................. 6
Water Connections ....................................................... 5
Water Circulation .......................................................... 8
Water Systems ............................................................ 14
GENERAL
Mexico Super RS
Natural Gas only Appliance type: C
11
Certified - P.I. No. 87 AT 14
Destination Countries: GB & IE.
Mexico Super RS 3/100 G.C. No 41 349 32
Mexico Super RS 3/125 G.C. No 41 349 33
NOTE TO THE INSTALLER: LEAVE THESE
INSTRUCTIONS ADJACENT TO THE GAS METER.
ALSO COMPLETE THE BENCHMARK LOG BOOK
AND GIVE THIS TO THE CUSTOMER.