Jonsered BV32 - Handle Fuel With Caution; Operate Your Unit Safely

PARTS LIST NO.
PAGE NO.
REPLACES
PARTS LIST
MODEL:
BV32
530068885 -- 8/07/02
Note: Illustrations may differ from actual models due to design changes
2
530068885--9/13/01
64 530019158 Crankshaft Seal
65 530032102 Outer Bearing
66 530015789 Retaining Ring
67 530014016 Crankcase Assy.
68 530039189 Flywheel Assy.
69 530347987 Washer
70 530023817 Starter Dog Spring
71 L Spacer--
See Service Ref. 3
72 530014156 Crankcase/Crankshaft Assy.
73 530016080 Screw
74 530015496 Screw
75 530027523 Retainer
76 L Starter Pulley (Incl.73)
--
See Service Ref. 1
77 530042085 Starter Spring
78 530069714 Fan Housing Kit (Incl. 71, 73--77, 79,
82--84, 86 & 105)
79 530027569 Starter Handle
80 530029117 Throttle Lock Button
81 530015769 Screw
82 L Bearing--
See Service Ref. 3
83 L Spacer--
See Service Ref. 3
84 L Screw--
See Service Ref. 3
85 530019167 ”O” Ring
86 530029182 Eyelet
87 530029227 Spark Arrestor Screen
88 530015702 “C” Clip
89 530029119 Rope Retainer Tube (Roll Pin)
90 530094710 Blower Housing (Upper)
91 530029173 Band
92 530047077 Impeller (Includes Hub)
93 530014339 Deflector & Clamp Ass’y.
94 530015818 Washer -- Impeller
95 530015441 Washer
96 530001733 Nut
97 530047736 Blower Housing (Lower)
(Incl. 100--103 & door)
98 530024772 Spring -- Throttle
99 530027597 Spring -- Lever Return
100 530015667 Spring -- Torsion (right)
101 530015647 Pin -- Pivot
102 530015815 Screw
103 530015672 Spring -- Torsion (left)
104 530069348 Spark Arrestor Kit
105 530069232 Rope Kit
106 530069247 Kit -- Line Carb./Purge
107 Operator’s Manual
530083432 Scandinavian
530083433 European
108 530069294 Gasket Kit (Incl. 35, 49, 50 & 54)
109 530015814 Screw
110 L Inlet Door--
See Service Ref. 4
111 530049185 Air Dam Sponge
112 530053346 Heat Shield / Air Dam
113 530019168 Grommet--Carb. Box
114 530019253 Seal Foam
530047885 Decal--Door Instruction
Description
Key
No.
Part
No.
Description
Key
No.
Part
No.
1 530094712 Handle
2 530026994 Front Isolator
3 530029111 Spacer -- Isolator
4 530015635 Screw
5 530029130 Rear Isolator
6 530015813 Screw
7 530029072 Trigger
8 530037595 Assist Handle Ass’y
9 530029228 Spark Arrestor Clamp
10 530029988 Exhaust Deflector Ass’y.
11 530015840 Pin -- Handle
12 534790500 Nut
13 530037864 Shroud--Right
14 530037934 Shroud--Left
16 530069572 Switch Kit
17 530029129 Isolator -- Engine Mount
18 530029295 Isolator -- Tank
19 530015814 Screw
20 530014162 Fuel Tank Ass’y. (Incl. #21,
22 & 106)
21 530014347 Fuel Cap (w/ retainer)
22 530095646 Fuel Pick--up Ass’y.
23 530014160 Handle Cover Assy.
24 530037865 Filter Cover
25 530029112 Air Filter
26 530029404 Air Baffle
27 530069293 Muffler Kit
28 530029116 Muffler Spring
29 952030201 Spark Plug (RCJ--8Y)
30 530001624 Screw
31 530069628 Cylinder Kit
32 530029145 Lead Wire Assy.
33 530039137 Ignition Module
34 530015816 Screw
35 530019178 Cylinder Gasket
36 530025875 Piston Ring
37 530069277 Piston Kit (Incl. #36,38, & Pin)
38 530015162 Wrist Pin Retainer
39 530015306 Screw
40 530029144 Ground Wire Assy.
41 530015849 Screw
42 530015254 Wave Washer
43 530015852 Choke Spacer
44 530029114 Choke Shutter
45 530015775 Screw
46 530037492 Cable Assembly
47 530029115 Air Filter Plate
48 530069644 Carburetor Kit (WT 141A w/ Limiter Cap)
49 530019164 Carb. Gasket
50 530019165 Foam Seal
51 530015771 Screw
52 530029113 Ground Wire
53 530047696 Reed Block / Heat Shield
54 530019166 Gasket
55 530027593 Reed Valve
56 530027594 Reed Stop
57 530016064 Screw
58 530014033 Crankshaft--
See Service Ref. 2
59 530015126 Flywheel Key
60 530010960 Connecting Rod Ass’y.
61 L Spacer--
See Service Ref. 2
62 530032103 Inner Bearing
63 530015787 Retaining Ring
n
=PART NUMBER CHANGE
L
=REFER TO THE SERVICE REFERENCE INDICATED FOR MORE INFORMATION.(LOCATED AT END OF IPL)
n
n
Not Shown
n
n
n
TYPE 1
TYPE 1