Kohler KDW 2204 - Coolant; Specifications Fuel

4.00
5.70
5.50
4
API CF4 - CG4
API CF
SPECIFICATIONS FUEL
- 31 - - 31 -
KDW
1603
KDW
2204/T
KDW
2204
Maintenance - Recommended oil type - Relling
COOLANT
Danger – Attention
- The uid coolant circuit is pressurized. Inspections must only be made when the engine has cooled and even in this
case, the radiator or expansion chamber plug must be unscrewed with the utmost caution.
- If an electric fan is installed, do not approach a hot engine since the fan itself could start up even when the engine is
at a standstill.
- Coolant uid is polluting, it must therefore be disposed of in the correct way. Do not litter.
The anti-freeze protection liquid (AGIP ANTIFREEZE SPEZIAL) mustbe used mixed with water, preferably decalcied.The
freezingpointofthecoolingmixturedependsontheproductconcentrationinwater,itisthereforerecommendedtousea50%
dilutedmixturewhichguaranteesacertaindegreeofoptimalprotection.Aswellasloweringthefreezingpoint,thepermanent
liquidalsoraisestheboilingpoint.
Prescribed coolant. Coolant refueling
Purchasedieselfuelinsmallquantitiesandstoreinclean,approvedcontainers.Cleanfuelpreventsthedieselfuelinjectorsand
pumpsfromclogging.Donotoverllthefueltank.
Leaveroomforthefueltoexpand.Immediatelycleanupanyspillageduringrefueling.
Neverstoredieselfuelingalvanizedcontainers;dieselfuelandthegalvanizedcoatingreactchemicallytoeachother,producing
akingthatquicklyclogsltersorcausesfuelpumporinjectorfailure.
Highsulfurcontentinfuelmaycauseenginewear.Inthosecountrieswheredieselhasahighsufurcontent,itsisadvisableto
lubricatetheenginewithahighalkalineoiloralternativelytoreplacethelubricatingoilrecommendedbythemanufacturermore
frequently.TheregionsinwhichdieselnormallyhasalowsulfurcontentareEurope,NorthAmerica,andAustralia.
FUEL TYPE
Forbestresults,useonlyclean,fresh,commercial-gradedieselfuel.Dieselfuelsthatsatisfythefollowingspecicationsare
suitableforuseinthisengine:ASTMD-975-1Dor2D,EN590,orequivalent.
FUELS FOR LOW TEMPERATURES
Itispossibletoruntheengineattemperaturesbelow0°Cusingspecialwinterfuels.Thesefuelsreducetheformationofparafn
indieselatlowtemperatures.Ifparafnformsinthediesel,thefuellterbecomesblockedinterruptingtheowoffuel.
Fuelcanbe: -Summer upto 0°C
 -Winter upto -10°C
 -Alpine upto -20°C
 -Arctic upto -30°C
BIODIESEL FUEL
Fuelscontaininglessthan20%methylesterorB20,aresuitableforuseinthis
engine.Biodiesel fuelsmeeting thespecication of BQ-9000or equivalentare
recommended.DONOTusevegetableoilasabiofuelforthisengine.
Anyfailuresresultingfromtheuseoffuelsotherthanrecommendedwillnotbe
warranted.
AVIATION FUEL
AviationfuelssuitableforuseinthisengineincludeJP5,JP4,JP8and,JET-A(if
5percentoilisadded).
PRESCRIBED LUBRICANT
Fuelwithlowsulphurcontent
Fuelwithhighsulphurcontent
EMISSION CONTROL INFORMATION
LOW SULFUR FUEL OR
ULTRA LOW SULFUR FUEL ONLY
EPA /CARB emission label must be
attached near the fuel inlet.
ENGINE TYPE
CAPACITY (Litres)
Without radiator
50% AGIP ANTIFREEZE
SPEZIAL
50% Water
Workshop Manual KDW 1603_2204_2204/T _ cod. ED0053029180 - 1° ed_rev. 00
ForinformationconcerningthecapacityofKohlerradiators,pleasecontactKohlerdirectly.
Thetotalvolumeforrellingthecoolingliquidvariesaccordingtothetypeofengineandradiator.