DIAGNOSTIC MANUAL MAN-00201
QUANTO EMS SEP 2012/Rev 1
The repair methods given by the manufacturer in this document are based on the technical specifications, current at the time of release. The methods may be modified as a result of changes introduced by the
manufacturer in the production of the various component units and accessories from which the vehicles are manufactured. The reproduction, translation, transmission, in part of or whole of the present document,
are prohibited without the prior written consent of Mahindra & Mahindra Ltd. The use of this document by any person other than the trained personnel, at the Authorized Service Centre of Mahindra & Mahindra Ltd.,
will amount to unauthorized use and shall be liable for penalty/prosecution© 2012 Mahindra & Mahindra Ltd.
`
GROUP DTC DISCRIPTION
PAGE
NO
FUEL TEMPERATURE SENSOR
P0183
SIGNAL RANCE CHECK FOR FUEL TEMPERATURE SENSOR
ABOVE MAXIMUM LIMITS
104
P0182
SIGNAL RANCE CHECK FOR FUEL TEMPERATURE SENSOR
BELOW MINIMUM LIMITS
109
IQA CODE MONITORING
P268C
CYLINDER 1 INJECTOR ADJUSTMENT CODE INCORRECT
ERROR
114
P268D
CYLINDER 2 INJECTOR ADJUSTMENT CODE INCORRECT
ERROR
116
P268E
CYLINDER 3 INJECTOR ADJUSTMENT CODE INCORRECT
ERROR
118
INJECTORS
P0201 CYLINDER 1 INJECTOR OPEN LOAD ERROR 120
P0203 CYLINDER 2 INJECTOR OPEN LOAD ERROR 124
P0204 CYLINDER 3 INJECTOR OPEN LOAD ERROR 128
P0261 CYLINDER 1 INJECTOR SHORT CIRCUIT ERROR 132
P0267 CYLINDER 2 INJECTOR SHORT CIRCUIT ERROR 136
P0270 CYLINDER 3 INJECTOR SHORT CIRCUIT ERROR 140
P2146 SHORT CIRCUIT IN BANK 0 144
METERING UNIT
P0001 METERING UNIT OPEN LOAD ERROR 150
P0004
METERING UNIT OUTPUT SHORT CIRCUIT TO BATTERY
ERROR
154
P0003
METERING UNIT OUTPUT SHORT CIRCUIT TO GROUND
ERROR
158
BOOST PRESSURE SENSOR
P0238
SRC HIGH FOR CHARGED AIR COOLER PRESSURE (DOWN
STREAM )
162
P0237
SRC LOW FOR CHARGED AIR COOLER PRESSURE (DOWN
STREAM )
167
RAIL PRESSURE SENSOR
P0193
SIGNAL RANGE CHECK FOR RAIL PRESSURE SENSOR
ABOVE MAXIMUM LIMIT
172
P0192
SIGNAL RANGE CHECK FOR RAIL PRESSURE SENSOR
BELOW MINIMUM LIMIT
177
P0191 RAIL PRESSURE OFFSET VALVE ABOVE MAXIMUM LIMIT 182
P1191 RAIL PRESSURE OFFSET VALVE BELOW MINIMUM LIMIT 184
ACCELERATOR PEDAL MODULE
P2123
SIGNAL RANGE CHECK FOR APP PEDAL SENSOR 1 ABOVE
MAXIMUM LIMIT
186
P2128
SIGNAL RANGE CHECK FOR APP PEDAL SENSOR 2 ABOVE
MAXIMUM LIMIT
191
P2138
PLAUSIBILITY ERROR BETWEEN APP SIGNAL 1 AND
SIGNAL 2
196
HFM SENSOR- TEMPERATURE
P0113
SIGNAL RANGE CHECK FOR HFM TEMPERATURE SENSOR
ABOVE MAXIMUM LIMIT
203
P0112
SIGNAL RANGE CHECK FOR HFM TEMPERATURE SENSOR
BELOW MINIMUM LIMIT
208
BOOST PRESSURE MODULATOR
P0045 BOOST PRESSURE MODULATOR OPEN LOAD ERROR 212
P0048
BOOST PRESSURE MODULATOR SHORT CIRCUIT TO
BATTERY
216
P0047
BOOST PRESSURE MODULATOR SHORT CIRCUIT TO
GROUND
220
P1645
BOOST PRESSURE MODULATOR OVER TEMPERATURE
ERROR
224
To Next Page
Loading...
Need help?
General
