3-10
SERVICING SCHEDULE
(1): MANDATORY 500 HOUR OR 6 MONTH SERVICE.
This service must be carried out after approximately the first 500 hours of operation or within the 6 months following the start-up of the machine
(whichever occurs first).
A = ADJUST, C = CHECK, G = GREASE, N = CLEAN,
P = BLEED, R = REPLACE, V = DRAIN
PAGE
(1)
DAILY OR EVERY 10
HOURS OF SERVICE
EVERY 50 HOURS OF
SERVICE
EVERY 250 HOURS OF
SERVICE
EVERY 500 HOURS OF
SERVICE OR EVERY 6
MONTHS
EVERY 1000 HOURS
OF SERVICE OR EVERY
YEAR
EVERY 2000 HOURS
OF SERVICE OR EVERY
TWO YEARS
EVERY 4000 HOURS
OF SERVICE
OCCASIONALLY
ENGINE
Engine oil level
3-12 C C <<< <<< <<< <<< <<< <<<
Cooling fluid level
3-13 C C <<< <<< <<< <<< <<< <<<
Fuel level
MI .. D
3-13 C C <<< <<< <<< <<< <<< <<<
Dry air filter cartridge
3-16/3-22
R N <<< R <<< <<< <<<
Radiator core
3-16 N N <<< <<< <<< <<< <<<
Engine oil
MI .. D
3-23 V V <<< <<< <<<
Engine oil filter
MI .. D
3-23 R R <<< <<< <<<
Engine oil
MI .. G
3-24 V V*** <<< <<< <<<
Engine oil filter
MI .. G
3-24 R R*** <<< <<< <<<
Fuel water trap
MI .. D
3-24 V V <<< <<< <<<
Alternator/fan/crankshaft belt tension
3-25 C/A C/A*** <<< <<< <<<
Engine idling
MI .. G
C C* <<< <<< <<<
Ignition timing
MI .. G
C C* <<< <<< <<<
Spark plug
MI .. G
C C* <<< <<< <<<
Rotor and ignition head
MI .. G
C C* <<< <<< <<<
LPG vacuum valve filter
From machine n° 856888
N/C N/C* <<< R* <<<
LPG vacuum valve
From machine n° 856888
C C* <<< <<< <<<
LPG vaporiser pressure regulator
From machine n° 856888
V/C V/C* <<< <<< <<<
LPG carburettor
From machine n° 856888
C C* <<< <<< <<<
Fuel filter
MI .. D
3-26 R R <<< <<<
Fuel pre-filter
MI .. D
3-26 R R <<< <<<
Safety dry air filter cartridge (**)
3-26 R <<< <<<
LPG vacuum valve filter
Up to machine n° 856887
C R* <<< <<<
LPG vacuum valve
Up to machine n° 856887
C C* <<< <<<
LPG vaporiser pressure regulator
Up to machine n° 856887
C C* <<< <<<
LPG carburettor
Up to machine n° 856887
C C* <<< <<<
Valve clearances
C C* <<< <<<
Engine silent blocks
C* <<< <<<
Engine speeds
C* <<< <<<
Cooling fluid
MI .. D
3-32 V <<<
Cooling fluid
MI .. G
3-33 V <<<
Fuel tank
3-34 N <<<
Injection pump
C* <<<
Injectors
C* <<<
Radiator
C* <<<
Water pump and the thermostat
C* <<<
Alternator and the starter motor
C* <<<
Fuel circuit
MI .. D
3-36 P
LPG cylinder
MI .. G
3-36/3-37
R
TRANSMISSION
Transmission oil level
3-20 C C <<< <<< <<< <<<
Differential oil level
3-20 C C <<< <<< <<< <<<
Transmission oil
3-27
V V <<< <<<
Transmission metal oil filter
3-27 N N <<< <<<
Differential oil
3-34 V V <<<
Brake wear
C*
TYRES
Wheel nuts torque
3-16 C C <<< <<< <<< <<< <<<
Wheel nuts tightening torque
3-34 C <<<
MAST
Tension and alignment of the mast lifting chains
3-16 C/A C/A <<< <<< <<< <<< <<<
Mast
3-17 G G <<< <<< <<< <<< <<<
Mast lifting chains
3-25 N/C/G N/C/G <<< C* <<<
Condition of mast unit
C* <<< <<< <<<
Attachment carriage
C* <<<
Chain rollers
C* <<<
Mast guide rollers
C* <<<
Mast bearing rollers
C* <<<
Thickness of the mast wearing plates
C* <<<
To Next Page
Loading...
