3-12
SERVICING SCHEDULE
(1): MANDATORY 500 HOUR OR 6 MONTH SERVICE
This service must be carried out after approximately the first 500 hours of operation or within the 6 months following the start-up of the machine
(whichever occurs first).
A = ADJUST, C = CHECK, G = GREASE, N = CLEAN,
P = BLEED, R = REPLACE, V = DRAIN
PAGE
(1)
DAILY OR EVERY 10
HOURS SERVICE
EVERY 50 HOURS
SERVICE
EVERY 250 HOURS
SERVICE
EVERY 500 HOURS
SERVICE OR 6
MONTHS
EVERY 1000 HOURS
SERVICE OR 1 YEAR
EVERY 2000 HOURS
SERVICE OR 2
YEARS
EVERY 4000 HOURS
SERVICE
OCCASIONALLY
I.C. ENGINE
I.C. engine oil level
3-14 C C <<< <<< <<< <<< <<< <<<
Cooling liquid level
3-14 C C <<< <<< <<< <<< <<< <<<
Fuel level
3-15 C C <<< <<< <<< <<< <<< <<<
Fuel pre-filter
3-15 C C <<< <<< <<< <<< <<< <<<
Cyclonic pre-filter
3-15 N N <<< <<< <<< <<< <<< <<<
Dry air filter cartridge
3-20/31 R C/N <<< R <<< <<< <<<
Radiator cores
3-20 N N <<< <<< <<< <<< <<<
Condenser core (OPTION Air conditioning)
3-20 C/N C/N <<< <<< <<< <<< <<<
Fan belt tension
3-26 C/A C/A <<< <<< <<< <<<
Alternator/crankshaft belt tension
3-26 C/A C/A <<< <<< <<< <<<
Compressor belt tension (OPTION Air conditioning)
3-27 C/A C/A <<< <<< <<< <<<
I.C. engine oil
3-30 V V <<< <<< <<<
I.C. engine oil filter
3-30 R R <<< <<< <<<
Fuel pre-filter
3-31 R R <<< <<< <<<
Fuel filter
3-32 R R <<< <<< <<<
CLEANFIX compressor filter (OPTION)
3-33 R R <<< <<< <<<
Fuel tank
3-36 N <<< <<<
Safety dry air filter cartridge
3-36 R <<< <<<
I.C. engine silent blocks
C** <<< <<<
I.C. engine rates
C** <<< <<<
Valves clearances
C** C** <<< <<<
Cooling liquid
3-42 V <<<
Radiator
C** <<<
Water pump and the thermostat
C** <<<
Alternator and the starter motor
C** <<<
Turbocompressor
C** <<<
Fuel system
3-44 P
TRANSMISSION
Gear box oil level
3-16 C C <<< <<< <<< <<< <<< <<<
Angle gear box oil level
3-28 C C <<< <<< <<< <<<
Gear box oil filter
3-33 R R <<< <<< <<<
Gear box oil
3-37 V V <<< <<<
Gear box sump strainer
3-37 N N <<< <<<
Angle gear box oil
3-39 V V <<< <<<
Silentblocks in the gear box
C** <<< <<<
Gear box controls
C** <<< <<<
Gear box pressures
C** <<<
Converter pressure
C** <<<
TYRES
Tyres pressure
3-16 C C <<< <<< <<< <<< <<< <<<
Wheel nuts torque
3-16 C C <<< <<< <<< <<< <<< <<<
Condition of wheels and tyres
C** <<< <<<
Wheel
3-45 R
Boom
Boom pads
3-16 G* <<< <<< <<< <<< <<< <<<
Boom
3-21 G G <<< <<< <<< <<< <<<
Boom pads wear
C** <<< <<<
Condition of boom unit
C** <<<
Bearings and articulation rings
C** <<<
HYDRAULIC
Hydraulic oil level
3-22 C C <<< <<< <<< <<< <<<
Hydraulic return oil filter cartridge
3-34 R R <<< <<< <<<
Hydraulic oil
3-39 V <<< <<<
Suction strainer for hydraulic oil tank
3-39 N <<< <<<
Filter cap for hydraulic oil tank
3-39 R <<< <<<
Distributor control head filter
3-39 R <<< <<<
Speeds of hydraulic movements
C** <<< <<<
Hydraulic pump pipe filter
(except ... LSU ...)
N** <<< <<<
Condition of hoses and flexible pipes
C** <<< <<<
Condition of cylinders (leakage, shafts)
C** <<< <<<
Hydraulic circuit pressures
C** <<<
Hydraulic circuit outputs
C** <<<
Hydraulic oil tank
N** <<<
To Next Page
Loading...
