Manitowoc MULTIPLEX 11M

To Next Page

To Previous Page

Section 2 Installation

Part Number 020001552 5/11 2-15

Model 11M Connections

John Guest Fittings

Drain Hose

Control Switches

Opening for Conduit Supply Lines

Main Page

Default Chapter1
- Refrigeration Unit1
- Safety Notices2
- Procedural Notices2
- Table of Contents3
Read this Manual7
Unit Inspection7
Model Numbers7
How to Read a Model Number7
- Section 1 General Information7
- Attention: Marine Installations8
Accessories8
Special Applications8
- Outdoor Applications8
Specifications8
Serial Plate Location9
Warranty Information9
General11
- Unpacking and Inspecting11
- Section 2 Installation11
Dimensions and Clearances12
- Remote Condenser13
- Blade Tower13
Safe Installation Dos and Don'ts14
- Kitchen Equipment Installer Representative Responsibilities15
- Requirements for Post MIX Units15
Location Requirements15
- Clearances15
- Ratings15
General16
- Grounding Instructions17
- Plumbing Requirements – General18
- Plumbing Potable Water18
Section 116
- Minimum Circuit Ampacity16
- Electrical Requirements16
Installer Instructions16
- Specifications16
- Preparation16
Electrical16
Plumbing/Water Supply18
- Plumbing Circuit Diagrams — Model 11M Root Beer19
Refrigeration Unit Installation22
- Positioning of Refrigeration Unit22
- Equipment Placement22
- Electrical Connections22
- Tower Installation22
- Routing Insulated Conduit22
- Connecting Insulated Conduit22
- Connecting Supply Lines23
Connect the Drain24
- Proper Use of John Guest Fittings24
- Insulating Connections26
Aeroquip Connection26
Condenser and Pre-Charged Lines Installation26
- Remote Condenser Requirements26
- Pre-Charged Refrigeration Line Requirements27
- Installing the Multiplex Remote Condenser27
- Connecting the Pre-Charged Refrigeration Lines28
- Testing CO 2 Circuit for Leaks28
- Testing Syrup Circuit (5 Gallon Tanks Only)28
Start-Up29
Preparing Ice Bank29
- Building an Ice Bank29
- Installation Section30
Installation Checklist30
Section 3 Operation31
Typical System31
How the Multiplex Works32
- Water Bath Access32
- Service Access32
Sequence of Operation32
- Pre-MIX Refrigeration Unit32
Start-Up33
- Placing Equipment in Operation33
- Placing the Carbonation System in Operation33
Equipment Setup and Close Procedure33
- Equipment Setup Procedure33
- Equipment Close Procedure33
Section 5 before Calling for Service39

Manitowoc MULTIPLEX 11M - Page 25

Table of Contents