FUMES AND TOXIC FUMES HAZARDS
Heated material and exhaust fumes contain poisonous carbon monoxide, which
carbon monoxide is colorless and odorless. Inhaling any fumes from the
equipment can cause death; do not used equipment in confined or enclosed
areas. Always use equipment in the outdoors or highly ventilated area.
• Any of the hot material and fumes can cause serious injury or death. Be very
careful not to drop cold material into hot material vat, splashing may occur and
cause serious injury.
• Make sure you read the proper SDS forms on material before using in equipment
and follow all safety hazards.
• BEFORE OPERATING YOUR NEW MARATHON EQUIPMENT check all nuts
and bolts for tightness. Bolts and nuts are tightened before leaving the factory.
However, some loosening may occur during shipment.
• Read this Operator’s Manual thoroughly and make sure that you are familiar with
ALL of the general and machine specific safety precautions before use.
• Wear protective clothing and relevant protective equipment at all times when
using this equipment.
• Observe all warning signs or notices on the machine.
• Always keep hands, feet and clothing away from moving parts, heating units,
and heated material.
• Never operate equipment in a confined space or in a closed building.
• Never operate the equipment while under the influence of alcohol or any
substance that might impair your vision, judgment, or ability to control the
equipment.
• Always make sure that all fittings are tight and leak-free.
• Check all connections, hoses and valves before each use.
• If equipped, do not move, tow or otherwise transport your equipment with the
burners lit.
• Check for and remove any standing water before filling the material bin.
• Always call your distributor or Marathon directly for replacement parts. Other
parts installed but not approved by the manufacturer could pose a safety hazard
or void your warranty.
NOTICE
Operators and persons responsible for maintenance of the equipment should read and understand this
manual thoroughly before operating the machine. If there are questions or concerns about how to safely
operate this equipment, contact Marathon or your dealer for clarification before attempting to use this
machine. Marathon Equipment Inc. will not assume liability for any injury or damages caused by improper
use, inadequate training or improper or inadequate maintenance of this machine.
To Next Page