Massimo GMF2X - PERIODIC SERVICE SCHEDULE

all rights reserved 15 OWNER’S MANUAL 2021-O-M-001
PERIODIC SERVICE SCHEDULE
√---CHECK C&A---CHECK&ADJUST CL---CLEAN R---REPLACE
SERVICE ITEM/INTERVAL
Before each use DAILY
5rounds/5 hrs 25 miles/40 kms WEEKLY
20rnds/20 hrs 100 miles/160 kms MONTHLY
60rnds/60 hrs 300miles/500 kms QUARTERLY
125rnds/125 hrs
600miles/1000 kms
SEMI-ANNUAL
250rnds/250 hrs 1200miles/2000 kms ANNUAL
Tires-pressure, condition of tires & rims
√
Hardware-loose or missing – tighten as necessary
√
Reverse Warning Indicator-sounds when F/R switch set
to reverse.
√
Overall Vehicle Condition
√
Batteries-state of charge, condition, loose terminals,
corrosion, hold down & hardware
√
CL
Brakes-smooth operation of pedal, and function of
service brake
√
C&A
Brakes-aggressive stop test, brake holds on a hill
√
Accelerator-smooth operation
√
Wiring-loose connections, broken or missing insulation
√
Charger- clean and check fault history
√
Charger Connector and Receptacle
√
Steering Assembly-excessive play, loose, missing
hardware or grease leakage
√
Tie Rods and Linkages-excessive play, bent rods, loose
or missing hardware
√
Rear Axle-oil leakage, noise, loose or missing hardware
√
Rear Axle-drain & replace fluid
C&A
R
Front Axel &Suspension-damage strut oil leakage,
excessive play in hubs or kingpins, worn bushings, loose
or missing hardware
√
Front Wheel Alignment-unusual tire wear
C&A
Rear Suspension-shock oil leakage, worn bushings,
loose or missing hardware
√
Wheel Bearings-check and adjust as necessary
√