MAINTENANCE
NOTE: Failure to follow these routine procedures may result in fail-
ures that are not covered under warranty.
Failure to follow maintenance procedures as outlined in this Owner’s
Manual may result in component failure. Such failure is not covered
under warranty. Failure may also result in loss of control or other
malfunction that could potentially lead to serious injury or death!
Hose o the brake rotors and calipers, along with all other parts of
the trailer that have come in contact with salt water or brackish wa-
ter, as this will minimize corrosion. A fresh water flush of the system
is the most critical aspect of trailer maintenance.
Extremely thick, heavy rust on rotor surfaces will not allow the wheel
assembly to rotate freely, resulting in heat build-up and premature
wear on components. Clean or replace components as necessary.
Brake pads must be replaced when 3/32” (.094”) or less of the pad
friction material is left.
Brake pad replacement should be performed by an authorized
MasterCraft dealer. Improper pad replacement may decrease
• Wheel bearings are properly adjusted and maintained
• Load is within the maximum load carrying capacity
• Load inside the boat is properly distributed
• Tires are properly inflated
• All trailer lighting is working properly
• Trailer brakes are properly adjusted and working (if trailer is
so equipped).
• Tower on the boat (if so equipped) is secure. It is upright and
locked in place, unless the tower can be locked in the down posi-
tion (ZFT4 and ZFT7).
• Sucient overhead clearance before removing the boat/trail-
er from cover, or when towing so that the unit will clear any
overhead items such as trees, bridges, overhead power lines,
overpasses, etc.
This trailer is manufactured to meet the applicable federal safety
standards at the time of manufacture. Check the local and state re-
quirements regarding any additional equipment that may be required.
NOTE: Trailer laws covering such things as brakes, lights, safety
cables, licenses, etc., will vary from state to state. Be sure that the
trailer is in full compliance with applicable state laws. An authorized
MasterCraft dealer can help in this regard. Otherwise, contact the
nearest state motor vehicle department.
2021MCOwnerManualFINAL.indd 429 8/26/20 1:55 PM
To Next Page
Loading...
Need help?
General
