• Relieve the load on the tires by supporting the trailer frame with
concrete blocks or jack stands.
• Lubricate moving parts such as the rollers and winch, as well as
the ball coupler.
• Tighten any loose nuts and bolts.
Extended Storage (In Excess Of One Year)
Follow the recommendations listed above for storage of several
months duration. Additionally:
• Check the brake system for fluid level in the master cylinder. If the
fluid level is low, air may be trapped in the brake lines. Bleed all
lines if necessary and fill the reservoir to the proper level.
• Lubricate all links and pivots to prevent rusting.
• Fill the frame (to avoid damage from vermin).
• Be certain the breakaway system has not been set and that the
actuator is fully extended.
• When possible, store away from excessive moisture.
TROUBLESHOOTING
this will adversely aect the fit of trailer to boat. This can result in
damage to the boat hull, which is not covered under warranty.
Storage (For Several Months)
• If at all possible, park the boat trailer in a protected, covered
area such as a garage, carport or similar shelter. Keep all canvas
covers on the boat while stored, but in higher humidity areas or
periods of weather, it may be necessary to open a corner of the
covered area to allow air circulation. See the Care and Mainte-
nance section of this Owner’s Manual for additional information
and suggestions regarding storage procedures.
• Have the wheel bearings checked by an authorized MasterCraft
dealer prior to reuse.
• Loosen the tie-downs and winch strap, but be sure the boat is still
resting properly on the hull supports (bunks).
• Remove the drain plug and elevate the trailer tongue slightly (just
an inch or two) to allow water to drain out so the boat will be dry.
Tie the drain plugs from the boat’s bilge system to something
obvious such as the steering wheel so that they will be easy to
remember to re-install before the next outing.
• A good time to touch up rust spots, nicks and chips is when the
trailer is in storage.
• Replace damaged tie-downs, winch straps, wiring, etc.
• Maintain proper tire inflation.
• Shield tires from UV rays (direct sunlight).
2021MCOwnerManualFINAL.indd 433 8/26/20 1:55 PM
To Next Page
Loading...
Need help?
General
