Mazda PROTEGE 1996 - Page 5

GENERAL INFORMATION
SAFETY INFORMATION ...................... Gl- 2
LUBRICANTS .•••••••...................... Gl- 2
JACKING POSITIONS ...................... Gl- 2
SAFETY STAND POSITIONS . . . . . . . . . . . . . . . . Gl- 2
VEHICLE LIFT POSITIONS •.•............... Gl- 3
DYNAMOMETER . . . . . . . . . . . . . . . . . .
• • • . . . . . . Gl- 3
COMPRESSED AIR ...........•••.......... Gl- 3
HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . Gl- 4
ADVISORY MESSAGES ...................• Gl- 4
PREPARATION ...••••••................... Gl- 4
REPAIR PROCEDURE .•.................... Gl- 4
SYMBOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gl- 5
IDENTIFICATION NUMBER LOCATIONS . . . . . . . Gl- 6
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . • . . Gl- 7
UNITS ..................•................... Gl- 8
SAE STANDARDS . . . . . . . . . . . . . . . . . . . . . . . . . . . Gl- 9
FUNDAMENTAL
PROCEDURES ............... Gl-11
PROTECTION OF THE VEHICLE ...........• Gl-11
PREPARATION OF TOOLS AND MEASURING
EQUIPMENT
........•.................... Gl-11
SPECIAL TOOLS ............•.•............ Gl-11
REMOVAL OF PARTS .....................• Gl-11
DISASSEMBLY ..........•................. Gl-11
REASSEMBLY .................•........... Gl-12
ADJUSTMENTS ......•••............•.••... Gl-13
RUBBER PARTS AND TUBING .............• Gl-13
HOSE CLAMPS ............................ Gl-13
TORQUE FORMULAS .....•................ Gl-13
VISE ........•............................. Gl-13
ELECTRICAL TROUBLESHOOTING TOOLS ... Gl-14
TEST LIGHT ....................•.......... Gl-14
JUMPER WIRE •..•........................ Gl-14
VOLTMETER ....................•......... Gl-14
OHMMETER •................••••.......... Gl-14
ELECTRICAL PARTS . . . . . . . . . . . . . . . . . • . . . . . . . Gl-15
BATTERY CABLE .....••..•• o •••••••••••••• Gl-15
CONNECTORS ............................ Gl-15
TERMINALS ........ o. o •••••••••••••••••••• Gl-16
SENSORS, SWITCHES, AND RELAYS ..•••.. Gl-16
WIRING HARNESS o •••••••••••••• o o •••••••• Gl-17
FUSE ...• o •••••••••••••••••••••••••••••••• Gl-17
INSTALLATION OF RADIO SYSTEM ........... Gl-17
TOWING .................................... Gl-18
PRE-DELIVERY INSPECTION ................. Gl-19
PRE-DELIVERY INSPECTION TABLE ........ Gl-19
SCHEDULED MAINTENANCE . . . . . . . . . . . . . . . . . Gl-20
SCHEDULED MAINTENANCE TABLE
(EXCEPT CANADA) . . . . . . . . . . . . . . . . . . . . . . . Gl-20
SCHEDULED MAINTENANCE TABLE
(CANADA) . . . . . . . . . . . . . . . . . . . . .
• . . . . . . . . . . Gl-23
Gl