MCC EM-1 - Compressor(s)

4-- 7© 2012 Mobile Climate Control T-299 Rev. 08/2012
4.9 COMPRESSOR(S)
If the compressor(s) is inoperative and the system
still has refrigerant pressure, recover the refrigerant
with an approved recovery/recycle m achine b efore
attempting rep air and/or replacement of the
compressor.
Always ensure the rep lacement compressor has the
correct amount of oil as specified by the
manufacturer.
Approximate oil charges:
A-6---10FluidOunces
TM-16 - - 6.08 Fluid Ounces (180CC)
TM-21 - - 8 Fluid Ounces
TM-31 - 16.9 Fluid Ounces
CAUTION
Unless there was a catastroph ic failure,
such as a blown or ruptured refrigerant
hose, additional oil may not be needed.
Refer to the specific compressor manufacturer's
service manual for proper maintenance and handling
procedures for th e co m p ressor installed o n your
vehicle.
NOTE
Mobile Climate Control does not
recommend chemical flushing of the
refrigeration system. If required, flushing is
to be performed usingthe system refrigerant.