MCCORMICK X60 Series - Routine Maintenance Guide

174
Maintenance
Every 10 hours (or daily) (Note 1)
 Generaltractorinspection(Note2)    X  176
 Frontwheelnuts(Notes3-4)  X    158
 Rearwheelnuts(Notes3-4)  X    168
 Fuellevel   X   177
 Transmission/hydraulicoillevel   X   178
 Engineoillevel   X   179
 Coolantrecoveryreservoirlevel   X   180
 Pneumatictrailerbrakesreservoir(ifequipped)  X    180

Every 50 hours (or weekly) (Note 1)
 Airpressureintyres(Note3)   X   151
 Fuelwatertrap-fuelfilter  X    181
 Radiatorandcoolers    X  182
 Engineairfiltervalve(Note7)(changeevery1000hours)(ifequipped)   X   183
 Enginedryairfiltercartridge(Notes5-7)    X  183
 Cabairrecyclefilter(Note6)    X  184
 Brakefluidreservoir   X   185
Every 100 hours (or every 2 weeks) (Note 1)
Brakeadjustment   X   186
 Parkingbrakeengagementcheck   X   187
 Oillevelinfrontaxlehousingandfrontepicyclicalfinaldrives   X   188
 Greasepoints(Note9) X     189
 Greasingpointsin4WDfrontaxleand4WDsleeve(Note9) X     190
 Frontthree-pointlinkage(ifequipped)(Note9) X     191
 CheckoillevelinfrontPTO(ifequipped)(Note8)   X   191
 Cabairintakefilter(Note6)    X  192
Every 250 hours (or monthly)
 Battery/ies   X   194
 Fanandalternatorbelt-Airconditioningcompressorbelt(ifequipped)
 (Checktensionafterthefirst50hours)   X   195
 Cleanoilfilteronhydrauliccircuitsintake(Note12)     X 196
 Replaceoilfilteronthedeliveryofthesteeringcircuit(Note12)     X 197
 Trailerhitchorautopick-uphitch,movingparts(Notes5-9) X     198
 Trailerhitch,bolttorques(Notes5-9)   X   198
 Drawbar,bolttorques(Notes5-9)   X   198
Every 500 hours (or every 6 months)
 Engineoilandoilfilter(Note10)     X 199
 Mechanicalenginefuelfilters(Note13)     X 200
 Electronicenginefuelfilters(Note13)     X 203
 Checkfunctionoftheoperatorpresenceswitch   X   205
 ChangeoilandcleanfrontPTOfilter(ifequipped)(Note8)     X 206
 Adjustmentoftheautohitch(ifequipped)   X   207
GREASE DRAIN CHECK CLEAN REPLACE SEEPAGE
HOURS SERVICE
OPERATION
REQUIRED
SERVICE POINTS
Routine maintenance guide