Chapter 7 Part B Automatic transmission
Contents
Automatic transmission - removal and installation
............ 8
Oil seal replacement
.......................... See Chapter 7A
Bands-adjustment .................................... 7 Shift linkage-check and adjustment ..................... -. . 3
Diagnosis-general .................................... 2 Throttle control cable/linkage-adjustment
.................. 4
Fluid and filter change ......................... See Chapter 1 Transmission mounts -check and rep!acement
.... See Chapter 7A
Fluid level check .............................
See Chapter 1 Transmission interlock cable (1992 and later models only) - check
General information .................................... 1 and adjustment
...............
__~_~_ ..... __ ........ __ ... 8
Neutral safety switch -check and replacement .......... , ... 5
SDecifications
Band adjustments
Kickdown band adjusting screw
Through1986 .... .._.........................._._._.
1987ihrough1989 ...................
..~...~.--.~~-~ .
1990 and later
Pick-ups ....................................... .._.
Monteros ..................... _. ......................
Low/reverse band adjusting screw
Through1986 .......................................
1987through1989
...............................
.._.
1,090 and
later
Pick-ups ..~.~.~~.~~~.~~...,........~..........~~
....
Monteros .........................
._
.........
_ .
-_
..
Transmission interlock cable clearance “A” ...................
Transmission interlock cable clearance “6” ..................
Torque specifications
Torque converter-to-driveplate bolts
....................
_
..
Kickdown band adjusting screw locknut
Through 1986 ................................ ._. .... .,_
1990andlater .......................................
Low/reverse band adjusting screw locknut
Through1986 .....
..~...._........_._..........____ _
IQQOandlater ................................. _ ____ __
Oil pan bolts
1983through1986 .............
.._........~.......- .-
1987through1989 .......... .............._.......__.
1990on ...........................................
Transmission-to-engine bolts
1983through1986 .. ..~............_...._....__ ......
19870n ..... ..L ...................................
3-l/2 turns backed-off from 52 in-lbs
No adjustments necessary
2-7/8 turns backed-off from 72 in-lbs
No adjustments necessar
7 turns backed-off from 43 in-lbs
No adjustments necessary
6 turns backed-off from
30 in-lbs
No adjustments necessary
0.08 to 0.1 inch
0.02 to 0.06 inch
Ft-lbs (unless otherwise indicated)
25
35
30
30
25
150 in-lbs
42 in-lbs
156 in-lbs
22to30
31 to 40
\
1 General information
All vehicles covered in this manual come equipped with either a five-
speed manual transmission or an automatic transmission. All information
on the automatic transmission is included in this, Part B of, Chapter 7. In-
formation on the manual transmission can be found in Part A of this Chap-
ter.
Due to the complexity of the automatic transmissions covered in this
manual and the need for specialized equipment to perform most service
operations, this Chapter contains only general diagnosis, adjustment and
removal and installation procedures.
If the transmission requires major repair work, it should be left to a deal-
er service department or an automotive or transmission repair shop. You
can, however, remove and install the transmission yourself and save the
expense, even if the repair work is done by a transmission shop.
To Next Page
Loading...
