Motorola PTP 54500 - Connecting up; Preparing the PIDU Plus to ODU Cable; Figure 16 - Correct Cable Preparation for the Recommended Cable

To Next Page

To Previous Page

7 Installation

7.7 Connecting Up

7.7.1 Preparing the PIDU Plus To ODU Cable

NOTE: The maximum cable length between the ODU and the user’s Network Equipment is

100m (330 ft). The cable should be assembled as shown in Figure 16:

Figure 16 - Correct Cable Preparation for the Recommended Cable

CAUTION: Check that the crimp tool matches the RJ45 connector being used.

Main Page

Default Chapter3
- Copyright Information3
- Table of Contents8
- Table 1 - Font Types21
- Table 2 - Admonition Types22
- Getting Additional Help23
- Sending Feedback23
1 About this User Guide21
- Interpreting Typeface and Other Conventions21
2 Avoiding Hazards24
- Preventing Overexposure to RF Energy24
- Calculations for Separation Distances and Power Compliance Margins24
- Table 3 - Power Compliance Margins25
3 Getting Started27
- For Your Safety27
- Welcome28
- Who Should Use this Guide28
- Contact Information28
- Repair and Service28
- Table 4 - Contact Information28
- Product Description29
- Figure 1 - Typical PTP 500 Series Bridge Deployment29
- The Outdoor Unit (ODU)30
- Figure 2 - PTP 500 Series Bridge Outdoor Unit (ODU) with PTP-LPU30
- PIDU Plus - PTP 300/500/600 Series Bridge31
- Figure 3 - Power Indoor Unit (PIDU Plus) - PTP 300/500/600 Series31
- Figure 4 - PIDU Plus Recovery Switch Location31
- Redundancy and Alternative Powering Configurations33
- Figure 5 -PTP 300/500/600 Series Bridge PIDU Plus Power Input33
- Figure 6 - External DC Supply Only33
- Figure 7 - External DC Supply and AC Supply34
- Figure 8 - External DC Supply and Redundant AC Supply34
- Remote Leds and Recovery Switch35
- Cables and Connectors35
- Figure 9 - Remote LED and Recovery Switch Wiring35
- PTP and Lightning Protection36
- Mounting Brackets36
- Configuration and Management37
- Warranty37
4 Product Architecture38
- Figure 10 - PTP 500 Series Bridge Layer Diagram39
5 General Considerations41
- Spectrum Planning41
- Table 5 - PTP 500 Series Bridge Frequency Variants41
- Licenses and Region Codes42
- Table 6 - PTP 58500 Licenses and Region Codes43
- Operational Restrictions44
- Radar Avoidance44
- Table 7 - PTP 54500 Licenses and Region Codes44
- Ghz Restrictions45
- Channel Bandwidth Operation46
- Figure 11 - 5.8 Ghz UK RTTT Channel Avoidance - 15 Mhz Channel Bandwidth Only46
- PTP 54500 Specific Frequency Planning Considerations47
- PTP 54500 Raster Considerations47
- Transmit Power Reduction at the Band Edges47
- Figure 12 - 5.4 Ghz Available Spectrum Settings - 15 Mhz Channel Bandwidth47
- PTP 58500 Specific Frequency Planning Considerations48
- PTP 58500 Raster Considerations48
- Figure 13 - 5.8 Ghz Available Spectrum Settings - 15 Mhz Channel Bandwidth48
- Ptp49
- 58500 Transmit Power Reduction at the Band Edges49
- Table 8 - PTP 58500 FCC Max Transmit Power at the Edge Channels (FCC)49
- Distance50
- Networking Information50
- Lightning Protection and Regulations50
- Electrical Requirements50
6 Site Planning51
- Site Selection Criteria51
- ODU Site Selection51
- PTP 500 Series Bridge PIDU Plus Site Selection51
- Path Loss Considerations52
- Definitions52
- Modulation Mode54
- Table 9 - PTP 54500 - IP Mode -System Threshold Figures - 15Mhz BW54
- Table 10 - PTP 54500 - TDM Mode - System Threshold Figures - 15 Mhz BW55
- PTP 58500 Product Variant - Link Loss, Output Power and System Threshold Versus Modulation Mode56
- Table 11 - PTP 58500 - IP Mode -System Threshold Figures - 15 Mhz BW56
- Table 12 - PTP 58500 - TDM Mode -System Threshold Figures - 15 Mhz BW57
7 Installation58
- Preparation58
- Installation Procedure58
- Tools Required59
- Installation Support59
- Legal Disclaimer59
- Mounting the Odus60
- Figure 14 - Mounting to Pole Diameters 25Mm (1") to 50Mm (2")60
- Figure 15 - Integral Safety Loop61
- Connecting up62
- Preparing the PIDU Plus to ODU Cable62
- Figure 16 - Correct Cable Preparation for the Recommended Cable62
- Figure 17 - Completed ODU Connector63
- Figure 18 - Warning Not to over Tighten Cable Gland63
- Making the Connections at the ODU64
- Figure 19 - PTP 500 Series Bridge PIDU Plus Connexion64
- Making the PTP 300/500/600 Series Bridge PIDU Plus Connection at the ODU65
- Figure 20 - Connecting the PIDU+ to the ODU65
- Routing the Cable66
- Fitting a Lightning Protection Unit66
- Figure 21 - Disconnecting the ODU66
- Grounding the Installation67
- Making the ODU Connection at the PTP 300/500/600 Series Bridge PIDU Plus67
- Making the Network Connection at the PIDU Plus - PTP 500 Series Bridge68
- Mounting the PTP 300/500/600 Series Bridge PIDU Plus68
- Figure 22 - Making the Network Connection at the PIDU Plus68
- Figure 23 - PTP 500 Series PIDU Plus Drip Loop Configuration69
- Powering up70
- Aligning the PTP 500 Series Bridge Odus71
- Table 13 - Audio Indications from the ODU71
- Table 14 - Graphical Installation Behavior72
- Figure 24 - Using DVM for Alignment73
- Additional Installation Notes74
8 Web75
- Figure 25 - Menu Navigation Bar76
- Home Page - PTP 500 Series Bridge77
- Figure 26 - System Summary Page77
- Home Page Alarm Display78
- Figure 27 - Alarm Warning Triangle78
- Systems Status Page83
- Figure 28 - Status Page83
- Equation 2 - Link Loss86
- System Administration88
- Figure 29 - System Administration Login Page88
- System Configuration89
- Figure 30 - System Configuration Page89
- Figure 31 - LAN Configuration Page91
- Figure 32 - Configuration Reboot Page92
- Figure 33 - Configuration Reboot Page - Ethernet Auto Negotiation Disabled92
- Figure 34 - VLAN Configuration Fields93
- Figure 35 - Qos Configuration Page94
- Table 15 - Qos Default Settings95
- Table 16 - Classification Rules Upgrade Example95
- Table 17 - IEEE802.1Q Classification Rules96
- Figure 36 - Save and Restore Configuration Page97
- Figure 37 - Save Configuration File Screen98
- Figure 38 - PTP 500 Example Configuration File98
- Figure 39 - Restore Configuration File Pop up Screen99
- Figure 40 - Reset Configuration and Reboot Confirmation Pop-Up100
- Statistics Page101
- Figure 41 - System Statistics101
- Detailed Counters Page104
- Figure 42 - Detailed Counters Page104
- Install106
- Table 18 - 500 Series Bridge Factory Configuration Values106
- Figure 43 - License Key Data Entry107
- Figure 44 - Installation Wizard Internet Protocol Configuration108
- Figure 45 - VLAN Warning109
- Figure 46 -PTP 58500 and PTP 54500 Variants - Installation Wizard Wireless Configuration110
- Figure 47 -PTP 58500 and PTP 54500 Variants - Fixed Frequency Operation113
- Figure 48 -PTP 58500 and PTP 54500 Variants - Installation Wizard Confirm Configuration114
- Figure 49 - Reboot Confirmation Pop up114
- Figure 50 -PTP 58500 and PTP 54500 Variant - Disarm Installation115
- Figure 51 - Optional Post Disarm Configuration 2116
- Graphical Install117
- Figure 52 - Graphical Installation Screen117
- Software Upgrade118
- Figure 53 - Software Upgrade118
- Figure 54 - Software Upgrade Image Check119
- Figure 55 - Software Download Progress Indicator120
- Figure 56 - Software Upgrade Complete120
- Spectrum Management121
- Figure 57 - Reboot Confirmation Pop up121
- Figure 58 - Spectrum Management as Seen from the Master124
- Figure 59 - Spectrum Management as Seen from the Slave124
- Figure 60 - Active Channel History Screen127
- Table 19 - Spectrum Management Change State Key127
- Figure 61 - Spectrum Management Time Series Plot128
- Table 20 - Spectrum Management Time Series Key128
- Spectrum Management (Fixed Frequency)129
- Figure 62 - Spectrum Management Fixed Frequency Screen129
- Spectrum Management Control - with Operational Restrictions130
- Figure 63 - Spectrum Management Help Page (Fixed Frequency)130
- Figure 64 - Spectrum Management Master Screen with Operational Restrictions131
- Figure 65 - Spectrum Management Slave Screen with Operational Restrictions132
- Table 21 - Spectrum Management Change State Key with Operational Restrictions133
- Remote Management Page134
- Figure 66 - Remote Management134
- Figure 67 - Warning When Disabling HTTP Interface135
- Figure 68 - Remote Management - Diagnostic Alarms136
- Diagnostics139
- Figure 69 - Diagnostic Plotter140
- Figure 70 - CSV Download141
- Change System Administration Password142
- License Key142
- Figure 71 - Password Change142
- Figure 72 - Software License Key Data Entry142
- Properties143
- Figure 73: License Key Reboot Screen143
- Figure 74 - Reboot Confirmation Pop up143
- Figure 75 - Properties143
- Reboot144
- Figure 76 - System Reboot144
- Figure 77 - Reboot Confirmation Pop up144
9 Recovery Mode145
- Figure 78 - Recovery Mode Warning Page145
- Figure 79 - Recovery Options Page145
- Upgrade Software Image146
- Figure 80 - Software Download Progress Indicator Page147
- Figure 81 - Software Download Complete Page147
- Figure 82 - Reboot Confirmation Pop up147
- Reset IP & Ethernet Configuration148
- Figure 83 - Confirm Reset to Factory Default Pop up148
- Figure 84 - IP and Ethernet Erased Successfully Page148
- Erase Configuration149
- Figure 85 - Reboot Confirmation Pop up149
- Figure 86 - Confirm Erase Configuration Pop up149
- Figure 87 - Erase Configuration Successful Page149
- Erase Security Parameters150
- Figure 88 - Erase Configuration - Reboot Confirmation Pop up150
- Figure 89 - Confirm Zeroise Security Parameters Pop up150
- Reboot151
- Figure 90 - Zeroise Security Parameters Successful Page151
- Figure 91 - Recovery - Reboot Confirmation Pop up151
10 Fault Finding152
- Hardware152
- Power152
- Ethernet153
- Checking Your Wiring154
- Table 22 - Power Indoor Unit LED Check Chart154
- Radio155
- No Activity155
- Some Activity156
11 Lightning Protection157
- Overview157
- Lightning Protection Zones157
- Figure 92 - ODU Mounted in Zones a & B158
- Detailed Installation159
- Figure 93 - Showing How the Use of a Finial Enables the ODU to be Mounted Inside Zone B159
- Figure 94 - Diagrammatically Showing Typical Mast and Wall Installations160
- Figure 95 - PTP LPU Installation Example for PTP 500 Series (Not to Scale)160
- Figure 96 - PTP 500 Series LPU Kit161
- Testing Your Installation162
- Figure 97 - Simplified Circuit Diagram162
- Pre-Power Testing163
- Table 23 - Resistance Table Referenced to the RJ45 at the PIDU163
- Post-Power Testing164
- Locating the Fault165
- Figure 98 - PTP LPU Test Points165
12 Wind Loading166
- General166
- Calculation of Lateral Force166
- Table 24 - Lateral Force - Imperial166
- Table 25 - Lateral Force - Metric166
- Capabilities of the PTP 500 Series Bridges167
- Wind Speed Statistics167
13 PTP 500 Series Bridge - Connectorized Model168
- Scope168
- Product Description168
- Hardware168
- Figure 99 - Connectorized 500 Series Bridge Outdoor Unit168
- Antenna Choices - 5.8 Ghz169
- Suggested Antenna Choices - 5.4 Ghz169
- Software/Features170
- Status Page170
- Figure 100 - Connectorized 500 Series Bridge Status Page170
- Configuration171
- Figure 101 - Connectorized 500 Series Bridge 'System Configuration' Page171
- Installation172
- Figure 102 - Connectorized PTP 500 Series Bridge 'Installation Wizard' Page172
- Figure 103 - Connectorized 500 Series Bridge 'Confirm Installation' Page173
- Deployment Considerations174
- Figure 104 - Connectorized 500 Series Bridge 'Disarm Installation' Page174
- Link Budget175
- Regulatory Issues175
- Antenna Choice (FCC and Industry Canada Regions Only)176
- Cable Losses (FCC Regions Only)176
- Table 26 - Cable Losses Per Length176
- Antennas for USA / Canada - 5.8 Ghz177
- Table 27 - Allowed Antennas for Deployment in Usa/Canada – 5.8 Ghz179
- Suggested Antennas - 5.4 Ghz180
- Table 28 - Suggested Antennas – 5.4 Ghz181
- Installation182
- Antenna Choice182
- Cables and Connectors182
- Tools182
- Miscellaneous Supplies183
- Mounting the Connectorized 500 Series Bridge183
- Mounting the Antennas183
- Alignment Process183
- Aligning Dual Polar Antennas184
- Aligning Separate Antennas184
- Completing the Installation185
- Antenna Cable Fixing185
- Antenna Connection Weatherproofing186
- Figure 105 - Forming a Drip Loop186
- Figure 106 - Weatherproofing the Antenna Connections186
- Additional Lightning Protection187
- ODU Mounted Outdoors187
- Figure 107- Additional Grounding When Using Connectorized Units187
- ODU Mounted Indoors188
- Figure 108 - Lightning Arrestor Mounting188
- Figure 109 - Polyphaser Assembly188
14 Data Rate Calculations189
- Figure 110 - BPSK 0.50 Single Payload189
- Figure 111 - QPSK 0.50 Single Payload190
- Figure 112 - QPSK 0.75 Single Payload190
- Figure 113 - 16 QAM 0.50 Single Payload191
- Figure 114 - 16 QAM 0.75 Single Payload191
- Figure 115 - 64 QAM 0.67 Single Payload192
- Figure 116 - 64 QAM 0.83 Single Payload192
- Figure 117 - QPSK 0.50 Dual Payload193
- Figure 118 - QPSK 0.75 Dual Payload193
- Figure 119 - 16 QAM 0.50 Dual Payload194
- Figure 120 - 16 QAM 0.75 Dual Payload194
- Figure 121 - 64 QAM 0.67 Dual Payload195
- Figure 122 - 64 QAM 0.83 Dual Payload195
15 AES Encryption Upgrade196
- Configuring Link Encryption196
- License Keys196
- Figure 123 - AES Software License Key Data Entry197
- Encryption Mode and Key198
- Figure 124 - AES Configuration Data Entry Page198
- Wireless Link Encryption FAQ199
- Encryption Data Entry Fields Are Not Available199
- Link Fails to Bridge Packets after Enabling Link Encryption199
- Loss of AES Following Downgrade199
- Figure 125 - Configuration Reboot Screen199
16 Legal and Regulatory Notices200
- Important Note on Modifications200
- National and Regional Regulatory Notices - PTP 58500 Variant200
- Federal Communication Commission (FCC) and Industry Canada (IC) Notification200
- European Union Notification201
- UK Notification202
- National and Regional Regulatory Notices - PTP 54500 Variant203
- FCC and Industry Canada (IC) Notification203
- European Union Notification204
- Exposure205
- Legal Notices206
- Motorola Inc. End User License Agreement206
- Hardware Warranty in U.S215
- Limit of Liability215
17 Specifications216
- System Specifications216
- Wireless PTP 54500 Variant216
- Wireless PTP 58500 Variant217
- Management218
- Ethernet Bridging218
- Physical219
- Powering219
- Safety Compliance219
- EMC Emissions Compliance220
- PTP 54500 Variant220
- PTP 58500 Variant220
- EMC Immunity Compliance221
- Radio Certifications222
- PTP 54500 Variant222
- PTP 58500 Variant222
- Environmental Specifications222
- System Connections223
- PIDU Plus to ODU and ODU to Network Equipment Connections223
- Figure 126 - Cable Connection Diagram (T568B Color Coding)223
18 Faqs224
19 Glossary226
20 Index227

Motorola PTP 54500 - Connecting up; Preparing the PIDU Plus to ODU Cable; Figure 16 - Correct Cable Preparation for the Recommended Cable

Table of Contents

Related product manuals