MRC MCX-5000 Series - Test Record of Auto-Exchanger System

MARINE RADIO CO.,LTD.
주/선박무선
Subject : Auto Exchanger Page : (44 / 46)
Date : 2010.10.13 Doc. : MCX-5000S_ENG_R1
(QAS-ADD-008/1/10.10.13) manual\pabx\mcx-5000S\MCX-5000S_eng.doc
( MARINE RADIO CO., LTD.)
MRC
㈜선박무선
SHOP TEST RECORD of
Auto-Exchanger
(자동전화교환장치)
Custome
r
(고 객)
Ship No.
(선 번)
-
Serial No.
(
제조번호
)
Type(형식)
MCX- Test Date
Place(검사장소)
MRC Shop Room Temp.
Test Record of Auto-Exchanger System
ITEM INSPECTION METHOD
STANDARD
LEVEL
MSR.
LEVEL
RESULT
REMAR
K
1. Verification
of Spec.
Check Purchase Order Specification. Check
2. Resistance
of Insulation
Measure resistance between power input and
case ground.(by DC500V)
More Than
10M
3. Withstand
Voltage
No change observed for 1 minute at AC2000V
between AC power input and chassis(ground)
Check
4. Transmitting
Loss
Measure of loss of voice signal loss on
connected phones(1kHz, 1V)
less than 6dB
5. Transmitting
Distortion
Measure of distortion in No. 2 state less than -30dB
6. Frequency
Characteristics
Measure of output frequency in No. 2 state
(300Hz ∼ 3kHz)
less than 6dB
7. Ring Signal Measure of output voltage of ring signal.
RMS:90V∼120v
8. Extension
Call
Measure of call, ring & voice after
connection of all phones
Functions(Call,
Ring & Voice)
9. Trunk Board
Measure of call, ring & voice after
phone's connection in trunk line
Voice Test
10. Paging Call Testing of paging with public address system Paging Test
11. Oscillating
Frequency
Measure of frequency on IC6 pin 10 using
Counter with 5pF condenser.
2000140 ±5Hz
12. Function
Test
Add-On Conference Testing
Must not be
trouble in ten
times testing.
Priority Call Testing
Camp On Testing
Warning Signal Testing
Self Diagnosis Testing
13.DC-24V Test
Testing of the above Stated Function with
DC-24V Power
The same as AC
Power line
14. Exterior
View Test
Confirm an external wound of painting
on case.(Color Name : )
Testing by the
naked eye
Confirm an fixing holes and dimension.
Compare with
Drawing
1. Requirement(요구조건)
-1. DNV Rule Pt.4 Vh.9 Sec.4B & DNV Standard For Cert’
2.4(JAN,2006)
-2. IEC60945
-3. IMO RES A.830(19) / 694(17)
-4. MRC Standard Re
q
uirements
(
include Manual
)
2. The Necessary Equipment
1. Audio Signal Generator : OS-9060D
2. Distortion Analyzer : HM-5010
3. RMS Volt Meter : SVM-135A
4. Insulation Tester : E17
3. Result : MRC Standard Shop Trial(제작자 표준 시험) -------------------------------
Tested
(
시험
)
Checked
(
검토
)
A
pp
roved
(
승인
)
Witnessed Witnessed Witnessed
Maker Maker Maker YARD CLASS OWNER