User manual
24 Trouble shooting
Defect
Engine cannot be started No fuel
Cause Rectification
Refuel
Charge battery, replace
Clean fuel filter
Replace pre-glow system
(service workshop)
Replace fuel line
Clean air filter
Warm up engine
Check cooling system
E NGINE
Battery power insufficient
Fuel filter contaminated
Pre-glow system defective
Fuel line leakage
Insufficient engine power Air filter contaminated
Engine not at operating temperature
Engine overheated
INDICAT OR L AMP S
Engine oil pressure indicator
lamp comes on during
operation
Oil pressure too low Stop engine immediately, check
oil level and top up if necessary
Check oil level If oil level is correct, oil pump is
defective
(service workshop)
Top up oil
Top up coolant
Re-tension V-belt
Clean air filter
Re-tension V-belt
Temperature display rises
above 100 °C
Oil level too low
Cooling water level too low
Fan blades rotate too slowly
Air filter contaminated
Charge monitor lamp comes
on during operation
Fuel display illuminated
Generator not charging properly
Insufficient fuel Refuel
9707672_user manual_en
- 72 -
To Next Page
Loading...