Panasonic KX MC6020 - Color Laser - All-in-One - User Maintenance; Service Maintenance

365
KX-MC6020HX
16.1.2.1. User Maintenance
The following table lists the user replaceable components and the symptoms that may result when they need to be replaced.
16.1.2.2. Service Maintenance
16.1.2.2.1. Recommended Maintenance Cycle
* Cleaning is recommended when replacing the Drum Cartridge.
16.1.2.2.2. Lubrication
Regarding the lubrication point, refer to the section 14 “Replacement Parts with Lubrication Guide”.
Printer Component Front Panel Message Average Life * Symptom
Toner Cartridge “Low <Color> Toner “
Have the <color> toner cartridge avail-
able.
“TC-* Replace“
(* indicates C, M, Y or K)
Replace the ** toner cartridge.
(** indicates Cyan, Magenta, Yellow or
Black)
4,000 pages
(Y, M, C, BK)**
2,000 pages
(Y, M, C)
2,500 pages
(BK
)
Uneven, streaky or mottled color.
Drum Cartridge “PC-* wearing out “
Have the * Drum Cartridge.
(* indicates Color or Black)
10,000 pages
(Color, BK)
Dark vertical streaks on the print.
Dark color spots and streaks in all colors.
A wide, light, horizontal band in one place
on the page.
All colors are faded; fine line detail disap-
pears.
“PC-* Replace “
(* indicates Color or Black)
Replace the* Drum Cartridge.
10,000 pages
(3 P/J)
Waste Toner Cartridge “WTC Full “
Have the Waste Toner Cartridge avail-
able.
----
“WTC Replace “
Replace the Waste Toner Cartridge.
8,000 pages/Full
color
Note * The rated life expectancy of each consumable is based on printing under specific operating conditions such as page
coverage for a particular page size (5% coverage per color at 600 x 600 dpi resolution on A4 size paper).
The actual consumable, life will vary depending on its use and other printing variables including page coverage, page
size, media type, print resolution, continuous or intermittent printing, number of color planes, ambient, temperature and
humidity.
When printing at the High Density, after “Low <Color> Toner “is displayed, a faded print may occur before “TC-*
Replace“is displayed. (* indicates C, M, Y or K)
** The Starter Toner Cartridges shipped with the printer have an average life of approximately 1,000 pages based on an
average of 5% coverage of A4 in continuous printing.
Item Maintenance Cycle Type of Maintenance
Paper Feed Unit Pickup Roller Approximately 50,000 pages Clean
Main Unit Paper Chute
Registration Roller
Inside of the printer *
Approximately 50,000 pages Clean
Area Part Lubricant Part Number Type of Lubricant
Main Drive Unit Gear and Gear Shafts PJOL-YM-103 Grease
Paper Exit Roller Roller Supporting Portion PJOL-YM-103 Grease