Page 16 of 18
10.0 SPARE PARTS
Spare Parts – PMNG-800HP Nitrogen Generator – SN:
0210-G137961-034818
QTY REFERENCE Part # DESCRIPTION
Stock
Level
Rec.
QTY
2 Filter 1 (4), Filter 3 (7) Q-095-15 Coalescing Filter Element, Pre-filters No. 1 & 3 1 2
1 Filter 2 (5) C-095-15/G4 Coalescing Filter Element, 2
nd
stage pre-filter 1 1
18 Carbon Tower (9) BM-000427 Air separation grade carbon (lbs.) 1 18
1 SV4 (38) VA-001822 Solenoid Valve,.5"NPT,N.O.,200PSI,120V 2 1
2 SV2 (25,39) VA-000131 Solenoid Valve,.5” NPT, N.C., 300PSI,120V 2 1
2 Membrane (19) RG-002672 Membrane, Nitrogen 3 0
1 PLC EC-000024 PLC, 10 AC In, 8 Relay Out, 120VAC 3 0
1 Operator Interface EC-000018 Panel, Operator Interface, EZ-220P 3 0
1 Cable EC-000019 Cable, PLC-Panel, EZ-2CBL 3 0
4 Regulator (31) VA-000807 Regulator, .125” 3 0
1 Relief Valve (6) VA-001531 ASME safety valve, 1/4", 150 PSI, 2 1
1 Heater (13) RG-000419 Circulation heater,.75 kW, 120-1-60 3 0
1 Check Valve (26) VA-002870 Check Valve,.5",EPR Seat 2 1
1 SSR 1 EC-001771 Solid State Relay, 25 AMP 2 1
1 1FU EC-002718 Fuse, 15 Amp, 250V, Glass 2 1
1 HC EC-001769 Heater Controller 3 0
1 APC EC-003865 Automatic Purity Controller, Dual Loop 3 0
1 AV (24) VA-003004 Automatic Purity Control Valve 3 0
3 PS1, PS2, PS3 EC-001962 Pressure Switch 2 3
1 DPG-PS4 GM-000503
Gauge,
∆
P Switch-Gauge, 0-15 PSID
3 0
3 Press Gauge (2,18,36) GM-000497 Gauge, 0-200 PSIG, 3.5” Dia., Panel Mount 2 3
1 Reg-Pilot (11) VA-000547 Precision Regulator, Pilot, .25”, CR200H 3 0
1 Flow Valve (22) VA-003013 Controller, Flow, Manual, .25” NPT 3 0
1 Regulator (12) VA-000566 Regulator, Pilot Operated, 1” 3 0
1 BV-1” (1) VA-000986 Valve, Ball, 1” NPT 3 0
3 BV-.25” (23) VA-000002 Valve, Ball, .25” NPT 3 0
1 BV-.5” (27) VA-000971 Valve, Ball, .5” NPT 3 0
1 TC (17) GM-000253 Thermocouple, 2.5” Stem, 5Ft PVC wire 2 1
1 TC Fitting (17) 2-2FH4BZ-B Thermocouple Fitting 2 1
1 TS1 (16) EC-002372
Thermostat, Sensor, 1-stage, -30-225
°
F
3 0
1 C1 EC-002598 Contactor, 20 AMP, Heater 2 1
1 SV3 (35) VA-001411 Valve, Solenoid, 3-way, Economizer 2 1
2 Needle Valve (21) VA-000086 Valve, Needle, .5” NPT 3 0
1 2FU EC-002612 Fuse, 2 AMP 2 1
10 3-4 FU, 6-12 FU EC-000280 Fuse, .5AMP, 250V, Glass 2 10
1 Regulator (29) VA-002864 Regulator, Pressure, 5000 PSI,0-250PSI, .25” NPT 3 0
1 5FU EC-002411 Fuse, 1 AMP, 250V,Glass 2 1
1 GND EC-002705 Ground Bar, 4-14 3 0
1 Flowmeter (20) GM-000759 Flowmeter, 0-130 SCFH 3 0
1 Flowmeter-O
2
(32) GM-000535 Flowmeter, .5-5SCFH, with SS Valve 3 0
1 BV-1”/Act (3) VA-002828 Valve, Ball, Brass, 1” NPT, with Actuator 3 0
1 SV1 (44) VA-001409 Valve, Sol, 4 Way, .25” 2 1
To Next Page
Loading...