POSSIBLE CAUSE SOLUTION
Water is present in fuel Drain the fuel system and refuel
Fuel valve is turned off Turn the fuel valve on
Old or non-recommended fuel Replace with fresh recommended fuel
Fouled or defective spark plug
(s)
Inspect plug(s) and replace if necessary
No spark to spark plug Inspect plug and replace if necessary
Water or fuel in crankcase Your POLARIS dealer can assist
Low battery voltage Recharge the battery with 12.8 VDC
Mechanical failure Your POLARIS dealer can assist
ENGINE RUNS IRREGULARLY, STALLS OR
MISFIRES
POSSIBLE CAUSE SOLUTION
Fouled or defective spark plug
(s)
Inspect, clean and/or replace spark plugs
Worn or defective spark plug
wires
Your POLARIS dealer can assist
Incorrect spark plug gap or
heat range
Set gap to specs or replace plugs
Loose ignition connections Check all connections and tighten
Water present in fuel Replace with new fuel
Low battery voltage Recharge battery to 12.8 VDC
Kinked or plugged fuel tank
vent line
Inspect and replace
Incorrect fuel Replace with recommended fuel
Clogged air filter Inspect and clean or replace
Throttle release switch
malfunction
Your POLARIS dealer can assist
Other mechanical failure Your POLARIS dealer can assist
96
TROUBLESHOOTING
To Next Page
Loading...
Need help?
General
