8.14
ELECTRICAL
9923983 - 2012-2013 RZR 170 Service Manual
© Copyright 2012 Polaris Sales Inc.
BATTERY
Battery Maintenance Service Notes
IMPORTANT: DO NOT activate Youth RZR batteries
unless they will be put into service within 30 days of
activation.
Youth RZR vehicles use a low maintenance battery. Do not
remove the battery cap strip to check acid level or add
water once the battery has been activated. Perform the
proper battery tests and charge or replace the battery as
required.
New batteries must be fully charged before use or battery
life will be significantly reduced (10-30% of the battery’s
full potential).
NOTE: DO NOT use a constant high-amperage
battery charger to charge this style of battery. Use a
low-amperage charger capable of charging voltage
that is 1/10 of the battery amp-hour rating.
New Battery Activation
To ensure maximum service life and performance from a
new battery, perform the following steps.
1. Remove the battery (1), battery acid (2), funnel (3)
and cap (4) from the box.
2. Remove the protective strip from the top of the battery.
Insert the battery electrolyte funnel into the filler holes.
3. Carefully press the battery electrolyte pack onto the
funnel. The funnel will puncture the pack seals,
releasing electrolyte into the battery. Allow the pack
to drain for 20 minutes, periodically tapping the sides
to release any air-lock or bubbles that may be present.
4. Properly dispose of the battery electrolyte pack. Let
battery set with the vent cap strip off for 30 minutes to
allow full absorption of the electrolyte. After 30
minutes, install the battery seal strip onto the battery.
5. Charge the battery initially for 3 to 5 hours using
Christie Charger (PA-37453) or a charger with an
output capable of 1/10th the battery’s amp-hour
rating.
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories contain lead and lead compounds
and other chemicals known to the State of
California to cause cancer, birth defects, or
other reproductive harm.
Always wear safety glasses, rubber protective
gloves and appropriate clothing when
working with batteries.
Battery electrolyte is poisonous. It contains sul-
furic acid. Serious burns can result from contact
with skin, eyes or clothing. Antidote:
External: Flush with water.
Internal: Drink large quantities of water or milk.
Eyes: Flush with water for 15 minutes and get
prompt medical attention.
Batteries produce explosive gases. Keep
sparks, cigarettes, etc. away. Ventilate when
charging or using in an enclosed space. Always
shield eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN
To Next Page
Loading...
