2
9931493 R03 - 2020-2021 Sportsman XP 1000 S Service Manual
© Copyright Polaris Inc.
2.5
MAINTENANCE INTERVALS
The maintenance interval charts outline required maintenance and inspection based on vehicle hours / miles. Each
table states the number of hours / miles that service is required on the vehicle. Some items or components may need
to be serviced more often due to severe use, such as operation in water or under severe loads. When the vehicle goes
beyond 500 hours / 5000 miles, return to the 25 hours / 250 mile chart and start the interval process over, disregard
any break-in services.
The following symbols denote potential items to be aware of during maintenance:
• XU Perform these procedures more often for vehicles subjected to severe use.
• D Have an authorized Polaris dealer perform these services.
• E Emission Control System Service (California)
25 HOUR / 250 MILE (400 KM) SERVICE
ITEM REMARKS
XU / D Brake Pad Wear
Inspect
XU
Engine Oil Break-in oil and filter change
XU Front / Rear Gearcase Fluid
Break-in fluid change
XU
Fuel System Check
Inspect; cycle key to pressurize fuel pump; check lines and fittings for
leaks and abrasion.
XU Transmission Fluid Break-in fluid level check
50 HOUR / 500 MILE (800 KM) SERVICE
ITEM REMARKS
Battery Check terminals; clean; test; replace as needed
XU / D Brake Pad Wear
Inspect
XU
Engine Oil
Check level
XU Front / Rear Gearcase Fluid Check level
XU
Front / Rear Suspension
Lubricate
XU
Fuel System Check
Inspect; cycle key to pressurize fuel pump; check lines and fittings for
leaks and abrasion.
XU General Lubrication
Lubricate all fittings, pivots, cables, etc.
Radiator
Inspect; clean external surfaces
Shift Linkage Inspect
XU Shock Absorbers
Inspect for leaks, loose joints, and wear
D
Steering
Lubricate
E
Throttle Body Intake Duct Inspect ducts for proper sealing / air leaks
XU Throttle Cable
Inspect; adjust; lubricate; replace if necessary
XU Transmission Fluid Check level
MAINTENANCE
To Next Page
Loading...
