Ski-Doo Mach Z User Manual

Section 03 TROUBLESHOOTING
Sub-Section 05 (SUSPENSION SYSTEM AND TRACK)
03-05-2
SYMPTOM DERAILING TRACK.
CONDITION NORMAL USE.
Test / Inspection 1. Check track tension.
a. Track is too loose.
Adjust.
2. Check if track and slider shoes are properly aligned.
a. Improper alignment.
Adjust.
SYMPTOM REAR SUSPENSION IS LOW OR TOO STIFF.
CONDITION NORMAL USE.
Test / Inspection 1. Check track tension.
a. Track is too tight.
Adjust.
2. Check if axles are properly lubricated.
a. Improper lubrication and / or contaminated grease (sticky oil sludge).
Clean and / or lubricate.
3. Check rear spring preload.
a. Insufficient preload.
Increase preload using shock adjustment cams.
SYMPTOM WHEN HANDLEBAR IS TURNED, SNOWMOBILE TURNS BEARLY OR NOT AT ALL.
CONDITION NORMAL USE.
Test / Inspection 1. Check ski runner condition.
a. Worn ski runners.
Replace.
2. Check tension of front spring adjustment cams.
a. Insufficient ski pressure on the ground.
Increase spring preload.
3. Check if front arm stopper strap is too long.
a. Insufficient ski pressure on the ground.
Shorten stopper strap.
4. Check front arm spring tension.
a. Insufficient ski pressure on the ground.
Slacken spring tension.

Ski-Doo Mach Z Specifications

General

Engine Displacement	899 cc
Horsepower	180 hp
Track Length	137 inches
Track Width	15 inches
Cylinders	2
Engine Stroke	2-Stroke
Cooling	Liquid
Fuel System	Electronic Fuel Injection (EFI)
Seating Capacity	1
Fuel Capacity	10.6 gallons
Brake System	Hydraulic