MAINTENANCE PROCEDURES
All Models
Check that the air silencer is clean and
dry and properly reinstall the filter.
NOTICE
Snowmobile engines
have been calibrated with the fil-
ter installed. Operating the snow-
mobile without it may cause engine
damage.
Engine Coolant
(V800 Model)
Engine Coolant Level
NOTICE
Vehicle must be on a level
surface before checking any fluid
levels.
Check coolant level at room tempera-
ture. Liquid should be at COLD LEVEL
line (engine cold) of coolant tank.
NOTE: When checking level at low
temperature it may be slightly lower
than the mark.
If additional coolant is necessary or if
entire system has to be refilled, refer
to an authorized Ski-Doo dealer.
mmo2007-001-002_a
EXPANSION RESERVOIR NEAR MUFFLER
1. Maximum
2. Minimum
Recommended Engine Coolant
Always use ethylene-glycol antifree
ze
containing corrosion inhibitors specifi-
cally for internal combustion aluminum
engines.
Cooling system must be filled with
BRP PREMIXED COOLANT (P/N 219
700 362) or with distilled water and an-
tifreeze solution (50% distilled water,
50% antifreeze).
Injection Oil (550F Model)
Injection Oil Level
NOTICE
Vehicle must be on a level
surface before checking any fluid
levels.
Always maintain a sufficient amount of
recommended injection oil in the injec-
tion oil reservoir.
NOTICE
Never allow oil reservoir
to be almost empty.
WARNING
Check level and refill every time
you refuel. Do not overfill. Wipe
off any spillage. Oil is highly
flammable when heated.
A29C0CA
1
2
TYPICAL
1. Injection oil reservoir
2. Maximum level: 13 mm (1/2 in) from top
_______________
67
To Next Page
Loading...
Need help?
General
