Sullair LS-200S

To Next Page

To Previous Page

Section 6

SUPERVISOR CONTROLLER

Figure 6-1 Supervisor Controller™ Control Panel

For information concerning all aspects of the Supervisor Controller,

consult the Supervisor Controller manual.

Main Page

Table of Contents3
General7
Personal Protective Equipment7
Pressure Release7
Fire and Explosion8
Hot Surfaces, Sharp Edges and Sharp Corners8
Moving Parts8
Toxic and Irritating Substances8
Electrical Shock9
Entrapment10
Description of Components11
Introduction11
Sullair Compressor Unit, Functional Description11
- Compressor Cooling and Lubrication System, Functional Description11
- Compressor Discharge System, Functional Description14
- Control System, Functional Description14
- Air Inlet System, Functional Description23
- Table of Specifications25
- Lubrication Guide- Standard Compressors25
Lubrication Guide- 24Kt Compressors26
Lubrication Guide- Optional Fluid26
Mounting of Compressor35
- Ventilation and Cooling35
- Service Air Piping35
- Coupling Alignment Check35
- Fluid Level Check35
- Motor Rotation Direction Check36
- Electrical Preparation37
- Purpose of Controls- Introduction39
- Purpose of Controls- Guide39
- Initial Start-Up Procedure40
- Subsequent Start-Up Procedure40
- Shutdown Procedure40
- General43
- Daily Operation43
- Maintenance after Initial 50 Hours of Operation43
- Maintenance Every 1000 Hours43
- Motor Bearings43
- Fluid Maintenance43
- Parts Replacement and Adjustment44
  - Procedures44
  - Air Filter Maintenance44
  - Fluid Filter Maintenance44
  - Separator Element Maintenance45
  - Oil Return/Sight Glass Maintenance45
  - Pressure Regulator Adjustment45
  - Compressors with Optional Spiral Valve46
  - Shaft Coupling Maintenance46
- Troubleshooting- Introduction49
- Troubleshooting Guide49
- Description of Components53
- Control System, Functional Description53
- Procedure for Ordering Parts69
- Recommended Spare Parts List69
- Motor, Compressor and Frame72
- Air Inlet System- Air-Cooled74
- Air Inlet System- Water-Cooled76
- Fluid Cooling System- Ls-200S & VCC-200S Air-Cooled78
- Fluid Cooling System- V-200S Air-Cooled80
- Fluid Cooling System- Water-Cooled82
- Air Piping System- Air-Cooled84
- Air Piping System- Water-Cooled86
- Fluid Piping System- Air-Cooled88
- Fluid Piping System- Water-Cooled90
- Moisture Drain- Air-Cooled92
- Sump and Parts94
- Pneumatic Controls- Ls-200S & VCC-200S98
- Pneumatic Controls- V-200S100
- Electrical Controls- Ls-200S & VCC-200S105
Electrical Controls- V-200S106
Electrical Controls- V-200S Externally Mounted110
Enclosure- Air-Cooled114
- Enclosure- Water-Cooled116
- Decal Group118
- Decal Locations- Open Air-Cooled124
Decal Locations- V-200S Open126
Decal Locations- Open Water-Cooled128
Decal Locations- V-200S Open Water-Cooled (380/575V+)130
Decal Locations- Ls-200S Enclosed Air-Cooled132
Decal Locations- V-200S & VCC-200S Enclosed Air-Cooled134
Decal Locations- Ls-200S Enclosed Water-Cooled136
Decal Locations- V-200S & VCC-200S Enclosed Water-Cooled138
Decal Locations- Control Box Enclosure140
Wiring Diagram- Ls-200S & Vcc200S with Supervisor Controller142
Wiring Diagram- Ls-200S & Vcc200S Wye-Delta with Supervisor Controller143
Wiring Diagram- Ls-200S & Vcc200S Full Voltage with Supervisor Controller144
Wiring Diagram- V-200S with Supervisor Controller145
Wiring Diagram- V-200S Ce with Supervisor Controller146

Sullair LS-200S - Page 41

Table of Contents

Related product manuals