Tennant T5 - Table of Contents

T5 9002333 REV.02 (07-06) iii
page
MACHINE INFORMATION
Component Locator…………...……………………………..……………… 1
Machine Specifications……………………….……………………………
…5
MAINTENANCE
CHARGING BATTERIES……………………………………………………7
Battery Charger Specifications………………...………………
…7
On-Board Battery Charger Settings……………………………
…7
Using the On-Board Battery Charger…………………………
…7
Using an Off-Board Battery Charger…………………………… 8
On-Board Battery Charger Error Codes………………………
…9
ADJUSTING SCRUB HEAD BRUSHES…………………………………
…10
Disk Brush Model………………...………………………………
…10
Cylindrical Brush Model…………………………………………
…10
MACHINE MAINTENANCE……………………………………………..…
…12
Daily Maintenance…………………………………………..……
…12
Monthly Maintenance………………………………….…………
…14
Battery Maintenance……………..………………………………
…15
Squeegee Blades……………………………...…………………
…15
Motor Maintenance……………………………………….………
…16
FaST System Maintenance………………………………………16
JACKING UP MACHINE……………...……………………………………
…17
TRANSPORTING MACHINE…………………….……………...…………
…17
STORING MACHINE………………………………………...…..…………
…17
FaST System Freeze Protection……………..…………………
…17
RECOMMENDED STOCK ITEMS……………..……………….…………
…18
BASIC TROUBLESHOOTING……………………….……………………
…20
CONTROL PANEL FAULT INDICATOR CODES…………………….…
…21
ELECTRICAL
Electrical Schematic…………………………...…..…………………..……
…22
Wiring Harness Detail………………………...………………..…………… 24
35 Pin Connector Detail………………..………………..…………………
…30
Control Panel LED Details…………………………………..…..…………
…31
Electrical Symbols & Terms…………………………...……………..……
…32
Key OFF Power Distribution
(Off-Board Charger Disconnected)…………………
33
Key OFF Power Distribution
(Off-Board Charger Connected)……………………
34
Key OFF Power Distribution
(On-Board Charger Disconnected)…………………
35
Key OFF Power Distribution
(On-Board Charger Connected)……………………
36
Key OFF Propel System………………...……………….…………………
…37
Key ON Power Distribution……………….………………………………… 38
Propel Forward System……………………………………………………
…39
Propel Reverse System……………………………………………………
…40
Propel System Neutral………………………………………………………
…41
Scrub Brushes……………………...…………………………..……………
…42
Vacuum Fan System…………………………..………………..…………
…43
Conventional Solution Solenoid Valve……………………………………
…44
FaST Water Pump…………….……………………………………………
…45
Hour Meter & Off-Aisle Wand Water Pump………………………………
…46
Scrub Head Actuator LOWER (Extend)…………………………………
…47
Scrub Head Actuator RAISE (Retract)……………………………………
…48
Operational Modes & Interlocks……………………………………………
…49
Diagnostic LED Codes……………………………………………………… 50
High Current Faults…………………………………………………………
…50
Diagnostic & Configuration Modes………………………………………… 51
Display Software Revision Mode…………………………………………
…52
Self Test Mode………………………………..……………………………
…54
Input Display Mode……………………………………………...…………
…55
Manual Mode…………………………………………………...……………
…57
Propel Diagnostics Mode…………………………………………………… 59
Battery Select Mode………………………………………………...………
…60
Supervisor Mode…………………………………………..………………… 61
Scrub Propel Speed Selection Mode……………………………………… 62
Scrub Head Selection Mode…………………………………..……………
…63
Inputs & Outputs Table………………………………………………….…
…64
T5 Service Information Manual
Table of Contents