NEVER REACH INTO BLOWER HOUSING FOR ANY REASON!
!
ITEM DESCRIPTION RECOMMENDED SERVICE
1. Blower Bearings Grease once a week or every 25 hours of operation.
2. Blower Power Band Re-tension after initial 10 hours; then check every 100 hours.
3. Blower Wheel Inspect monthly for wear. DO NOT REACH INTO BLOWER HOUSING
FOR ANY REASON!
4. Gutter Broom / Wafer Check DAILY for string, cassette tape, etc on motor shaft. Re-tension
spring when new wafers are installed.
5. Hydraulic Reservoir Change oil every 2000 hours or by oil analysis recommendation. Check
oil level DAILY.
6. Hydraulic Oil Filter Change every 1000 hours or as indicated by restriction indicator.
7. Aux. Engine Air Cleaner Replace when restriction indicator shows red.
8. Auxiliary Engine Change oil every 100 hours, for additional service refer to engine man-
ual. Check oil level DAILY.
9. Console Fuse Panel Always replace fuse with identical amp rating.
10. Both Engine Radiators Check DAILY. CAUTION - Check only when cold.
11. Truck Air Cleaner Service every 25 hours or when restriction gauge indicates.
12. Transmission Change oil & fi lter every 15,000 miles or once a year.
13. Water Tank Drain tank DAILY.
14. Centrifugal Separator Wash out DAILY! Cleanout door provided on engine side.
15. Separator Seal Clean seal DAILY. Hopper must be airtight and fi t snuggly against seal
when lowered.
16. Skimmer Hood Inspect DAILY! Skimmer hood must swing freely when hopper is raised
in order to clean itself of debris.
17. Hopper Screen Wash DAILY to prevent air blockage.
18. Hopper Wash out at end of each shift to prevent rusting.
19. Dump Door Seal Inspect DAILY; replace if damaged.
20. Hopper Pivot Hinge Grease every 25 hours of operation or once a week. CAUTION: Hop-
per must be raised in order to grease hinge. Always Install Pin in Lower
Safety Strut!
21. Truck Tires Check DAILY for fl ats and correct air pressure.
22. Spring Tension Check skid plates weekly for wear; adjust spring tension as required.
23. Pick-Up Head Curtains Inspect DAILY; replace when worn out .
24. Drag Link Inspect DAILY for condition
25. Truck Engine Change oil and fi lter every 100 hours or 3000 miles of operation.
To Next Page
Loading...