Westward 22XP38 - Working Area and Safety; Working Area Safety Precautions; Electric Safety; GFCI Testing and Extension Cord Use

4
Westward Operating Instructions and Parts Manual
22XP38, 22XP39
Drain Cleaning Machine
permanentgroundsuchasaproperlygroundedoutletboxcover.Whenevertheadaptorisused,
itmustbeheldinplacebythemetalscrew.

WorkingAreaandSafety
1. Donotletwatergetintothepowertools.Ifthemachineiswet,donotoperateituntilitis
dry.Donotoperatemachinewhenitisstandinginwater.Thiswillincreaseriskofelectrical
shock.
2. Wearsafetyequipment(glovesandrubber
soled,non‐slipshoes)andapplysafety
procedureswhenworkingareaiswet.Placethemachineonadrysurface.
3. Neveroperatemachinesinexplosiveenvironments,includingareaswithflammableliquids,
gasesordust.Powertoolscreatesparkswhichmayignitethedustorfumes.
4. Becautiouswhen
cleaningdrainswithcleaningchemicalsbeingapplied.Donotletthe
chemicalsdirectlycontactskin,eyesand/orthecable.Thesechemi calscancauseserious
burnstotheskinandeyesaswellasdamagingthecable.
5. Haveasecondpersonsupervisewhenworkinginanarrowspaceorspecialenvironment,

suchasinaboilerroom,insideapipeoronawetsurface.Failuretodosomaycause
seriousinjuryordeath.
6. Keepbystanders,children,andvisitorsawaywhileoperatingthepowermachine.
Distractionsbyothersmayleadtolosingcontrol.
7. Keepworkingareawelllit,
neatandclean.Darkzonesandclutteredmessescause
unpredictableaccidents.

ElectricSafety
1. ThemachineisequippedwithaGroundFaultCircuit
Interrupter(GFCI),whichprotectsyouagainstshockifshort
circuitshouldoccur.Checkthatthereceptacleisproperly
grounded.TesttheGFCIbeforeeachuse.Thetestingprocedure

isgivenbelow:

a) Plugmachineintoareceptaclewiththemachine‐specified
voltage.
b) Pushthetestbutton.Indicatorlightwillgooutandpower
tomachinewillcutoff.

Iflightdoesnotgooutwhenthetest
buttonispushed,equipmentshouldnotbeuseduntil
properrepairsorreplacementtotheGFCIaremade.
c) Torestorepoweraftertest,pushresetbutton.

Withtheresetbuttonuntouched,ifthemachinedoesnotstart,or
stopswhilerunning,orifyouexperienceamildshock,donotusethemachine!Have
itrepairedorreplacedbyalicensedtechnician.
Whenusinganextensioncord,theGFCIonthedraincleanerdoesnot
protecttheextensioncord.IftheoutletisnotGFCIprotected,itisadvisabletousea
plugintypeGFCIbetweentheoutletandtheextensioncordtoreducetheriskof 
shockifthereis
afaultintheextensioncord.

2. Whenworkingwiththemachineoutside,useaspeciallydesignedoutdoorextensioncord.
Thiskindofcordreducestheriskofelectricshock.Useonlythree‐wireextensioncords
whichhavethree‐prongedgroundingplugsandthree‐polereceptacleswhichacceptthe
tool’s
plug.Useofotherextensioncordswillnotgroundthetoolandincreasetheriskof
electricshock.Insufficientconductorsizewillcauseexcessivevoltagedropandlossof
power.Whenusingextensioncords,aGFCImustbeusedincircuitboxesoroutlet
receptacles.ExtensioncordswithoutaGFCIcan
alsocauseelectricshock.